2007 Fleetwood Bounder problems: recalls, complaints and what to check
NHTSA has 6 recalls and 5 owner complaints on file for the 2007 Fleetwood Bounder. Here is what they are, what a technician checks for each kind of fault, and how to look one over before you buy it.
Other: 4 recalls, 4 complaints
Recall 08V240000 (03/06/2008): EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
FLEETWOOD IS RECALLING CERTAIN CLASS A GAS AND DIESEL MOTOR HOMES, CLASS C MOTOR HOMES, CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH NORCOLD REFRIGERATORS. A LOW CYCLE FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH GENERATES THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.
Fix: FLEETWOOD IS WORKING WITH NORCOLD TO REPAIR THESE REFRIGERATORS. NORCOLD WILL PROVIDE THERMAL SWITCH KITS TO OWNERS ALONG WITH THE NECESSARY FORMS AND INSTRUCTIONS. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2008. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR FLEETWOOD AT 1-800-509-3418.
Recall 08V320000 (15/07/2008): EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
FLEETWOOD IS RECALLING 70,101 MY 2003-2007 SOUTHWIND, PACE ARROW, BOUNDER, FLAIR, STORM, FIESTA, TERRA GAS CLASS A MOTOR HOMES; BOUNDER, DISCOVERY, PROVIDENCE, EXCURSION, EXPEDITION, REVOLUTION, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION DIESEL CLASS A MOTOR HOMES; JAMBOREE TIOGA CLASS C MOTOR HOMES; AND PROWLER, WILDERNESS, TERRY, MALLARD, PIONEER, PRIDE AND TRIUMPH CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATORS MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Fix: FLEETWOOD IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.
Recall 07V503000 (25/10/2007): EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
ON CERTAIN MOTOR HOMES, THE SLIDE-OUT ROOM MAY ACTIVATE WHILE TRAVELING, CAUSING THE OVERALL VEHICLE WIDTH TO INCREASE.
Fix: DEALERS WILL INSPECT AND IF NECESSARY, RELOCATE CERTAIN ELECTRICAL COMPONENTS AND SEAL ASSOCIATED COMPARTMENTS FROM THE ELEMENTS. THE RECALL BEGAN ON JANUARY 11, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-322-8216.
Recall 07V504000 (25/10/2007): EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
ON CERTAIN MOTOR HOMES, THE SLIDE-OUT ROOM MAY ACTIVATE WHILE TRAVELING, CAUSING THE OVERALL VEHICLE WIDTH TO INCREASE. WATER CAN SHORT OUT THE ELECTRONIC CONTROL RELAY FOR THE SLIDE-OUT ROOM CONTROL MECHANISM.
Fix: DEALERS WILL INSPECT AND IF NECESSARY, RELOCATE CERTAIN ELECTRICAL COMPONENTS AND SEAL ASSOCIATED COMPARTMENTS FROM THE ELEMENTS. THE RECALL BEGAN ON JANUARY 11, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-322-8216.
Axles, brakes, suspension and hitch: 1 recall, 1 complaint
Recall 09V198000 (02/06/2009): SERVICE BRAKES, AIR
FLEETWOOD IS RECALLING 509 MY 2001-2008 CLASS A MOTOR HOMES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.
Fix: DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. WORKHORSE IS HANDLING THE REMEDY FOR THIS CAMPAIGN PLEASE SEE 09V-110. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731. WORKHORSE WILL CONDUCT THE OWNER AND DEALER NOTIFICATION.
What a tech checks: Bearings, brake magnets, worn shackle bolts and bent axles. A trailer that wears tires on the inside edge or pulls to one side usually has an axle or suspension problem. Before you buy: Bolts tight, springs not flat, brakes apply with the breakaway pin pulled.
Chassis and towing lessons · Trailer guide
Motorhome chassis: 1 recall
Recall 06V388000 (04/10/2006): ENGINE AND ENGINE COOLING
ON CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH GENERAL MOTORS 8.1L V8 ENGINES, IMPROPER HARDENING DURING THE HEAT TREATMENT PROCESS CAN CAUSE THE FUEL RAIL PULSE DAMPER RETAINER CLIP TO FRACTURE, RESULTING IN INADEQUATE RETENTION OF THE DAMPER. IF THE DAMPER BECOMES LOOSE, FUEL COULD BE PUMPED BY THE FUEL PUMP INTO THE UNDER HOOD AREA.
Fix: WORKHORSE IS HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN (PLEASE SEE 06V225). DEALERS WILL REPLACE THE FUEL RAIL PULSE DAMPER RETAINER CLIPS ON THESE ENGINES FREE OF CHARGE. OWNERS MAY CONTACT WORKHORSE AT 877-294-6773 OR FLEETWOOD AT 1-800-322-8216.
What a tech checks: The chassis (Ford, Freightliner, Mercedes, Ram) is serviced by the chassis maker's dealer, not the RV shop. RV techs handle the house, not the drivetrain. Before you buy: Chassis recalls are fixed free at the chassis maker's dealer.
Doors, windows, steps and lights: 1 complaint
What a tech checks: Mostly adjustments and wear: steps that stop halfway on a bad switch, doors out of alignment after a slide shifted, exterior lights with a corroded ground. Before you buy: Every door, lock, window and light.
What owners reported to NHTSA
12/13/2010, EQUIPMENT: TL*THE CONTACT OWNS A 2007 FLEETWOOD BOUNDER EQUIPPED WITH A NORCOLD REFRIGERATOR, MODEL NUMBER 1200LR1M. THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 09E027000 (EQUIPMENT). THE MANUFACTURER WAS NOTIFIED ON NUMEROUS OCCASIONS REGARDING THE RECALL DEFECT; HOWEVER THERE WAS NO ASSISTANCE PROVIDED. IN ADDITION, THE DEALER INFORMED THAT THE RECALL PART WAS UNAVAILABLE AND THEY WERE UNCERTAIN OF THE ARRIVAL
08/21/2010, VISIBILITY: FOGGY DOUBLE WINDOWS IN THE DRIVERS CAB OF A 2007 FLEETWOOD BOUNDER. SE-GI WINDOWS. COULD NOT SEE REAR VIEW MIRRORS. WE HAD THE INSIDE PANE OF THE STATIONARY WINDOW TAKEN OUT BY A GLASS INSTALLER. WE GOT NO HELP FROM FLEETWOOD OR SE-GI. 7 OF 10 WINDOWS ARE FOGGING. WE FIRST NOTICE IT A YEAR AND A HALF AFTER WE BOUGHT THE NEW MOTORHOME. *TR
07/16/2010, SERVICE BRAKES, AIR: TL* THE CONTACT OWNS A 2007 FLEETWOOD BOUNDER WITH A WORKHORSE CHASSIS. THE CONTACT STATED WHILE DRIVING AT 40 MPH WITH THE RV ATTACHED TO HIS VEHICLE, THERE WAS A BURNING ODOR IN THE VEHICLE. THE CONTACT FOUND THAT THE ODOR WAS COMING FROM THE REAR OF THE VEHICLE AND DISCONNECTED THE VEHICLE FROM THE RV. HE THEN STARTED THE RV AND NOTICED THAT THE BRAKE PEDAL HAD FELL INTO THE FLOORBOARD. THE ABS WARNING LIGHT WAS A
06/21/2007, UNKNOWN OR OTHER: 2007 FLEETWOOD BOUNDER MOTORHOME. DRIVERS'S SIDE SLIDE-OUT MOVES OUT ANYWHERE BETWEEN 2 TO 18 INCHES WHILE DRIVING VEHICLE. VEHICLE HAS BEEN TAKEN TO DEALERS TWICE FOR DIAGNOSIS/REPAIR. FIRST TIME WAS DIAGNOSED WITH ALIGNMENT PROBLEM AND THE SLIDE-OUT WAS ALIGNED. SECOND TIME WAS DIAGNOSED AS BRAKE RELEASE PROBLEM. BOTH TIMES REPAIRS WERE UNSUCCESSFUL. MANUFACTURER WANTS TO TRY TO AGAIN REPAIR SLIDE-OUT, HOWEVER
01/07/2007, VEHICLE SPEED CONTROL: CRUISE CONTROL GETS STOCK. WHEN ENGAGING ACCELERATION MODE AND SPEED ACCELERATE TO MORE THAN 10 INCREMENTS MILES WHEN DRIVING AT HIGHWAY SPEEDS. DEPRESSING DECELERATE WILL NOT LOWER THE SPEED AT ALL. CRUISE CONTROL MUST BE DISENGAGED TO STOP DECELERATION. *NM
Looking at a 2007 Fleetwood Bounder?
The Buyer's Check walks you through it on your phone: what to ask, the outside walk-around, water damage, every system on every power source, with the recalls above built in. You get a report that says what's a walk-away and what to negotiate on.
Checked against NHTSA 2026-10-23. Recall repairs are free at an authorized dealer. Complaints are owner reports to NHTSA and are not verified.