2011 Fleetwood Bounder problems: recalls, complaints and what to check
NHTSA has 2 recalls and 2 owner complaints on file for the 2011 Fleetwood Bounder. Here is what they are, what a technician checks for each kind of fault, and how to look one over before you buy it.
12 volt and 120 volt electrical: 2 recalls
Recall 11V298000 (24/05/2011): ELECTRICAL SYSTEM:WIRING
FLEETWOOD RV IS RECALLING CERTAIN MODEL YEAR 2011 BOUNDER CLASSIC, STORM AND TERRA CLASS A MOTOR HOMES BUILT ON FORD CHASSIS AND MANUFACTURED FROM MAY 21, 2010, THROUGH FEBRUARY 11, 2011. CERTAIN MODEL YEAR 2011 BOUNDER AND SOUTHWIND CLASS A MOTOR HOMES BUILT ON FORD CHASSIS AND MANUFACTURED FROM MAY 24, 2010 THROUGH MAY 18, 2011; AND CERTAIN MODEL YEAR 2012 BOUNDER AND SOUTHWIND CLASS A MOTOR HOMES BUILT ON FORD CHASSIS AND MANUFACTURED FROM MAY 16, 2011 THROUGH JUNE 15, 2011. A WIRE HARNESS THAT IS ROUTED UNDER THE MOTOR HOME, NEAR THE CHASSIS RAIL, CAN CONTACT A HEAT SHIELD LOCATED NEXT TO THE PASSENGER SIDE ENGINE EXHAUST MANIFOLD. THE CLOSE PROXIMITY CAN CAUSE THE HARNESS TO MELT OR BE OTHERWISE DAMAGED.
Fix: DEALERS WILL INSPECT AND REROUTE THE WIRE HARNESS AWAY FROM THE HEAT SHIELD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JUNE 2011. OWNERS MAY CONTACT FLEETWOOD OWNER RELATIONS AT 1-800-509-3418.
Recall 11V399000 (03/08/2011): ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
FLEETWOOD RV IS RECALLING CERTAIN MODEL YEAR 2010 AMERICAN EAGLE, AMERICAN TRADITION, DISCOVERY, REVOLUTION LE, AND MODEL YEAR 2011 AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION, BOUNDER, BOUNDER CLASSIC, DISCOVERY, EXPEDITION, PROVIDENCE, REVOLUTION LE, AND SOUTHWIND CLASS A MOTOR HOMES EQUIPPED WITH MURRAY OR SIEMENS BRAND CIRCUIT BREAKERS. THESE CIRCUIT BREAKERS HAVE A NON-CONFORMING "SPRING CLIP" PLUG-IN ASSEMBLY THAT BREAKS OR FAILS TO PROVIDE SUFFICIENT FORCE TO MAINTAIN A PROPER ELECTRICAL CONNECTION IN THE PANEL BOARD.
Fix: DEALERS WILL INSPECT AND REPLACE THE CIRCUIT BREAKERS IF NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 25, 2011. OWNERS MAY CONTACT FLEETWOOD OWNER RELATIONS AT 1-800-509-3418.
What a tech checks: Voltage drop, grounds, the converter and the transfer switch. Melted shore-cord plugs and bad grounds cause most of the electrical complaints techs actually see. Before you buy: Battery at rest, converter output on shore power, GFCI test, every outlet.
12 V electrical lessons · 120 V and generator lessons · Wiring diagrams
Structure, roof and leaks: 1 complaint
What a tech checks: Roof sealant, seams, window and slide seals, and the frame. Water intrusion shows up as delamination, soft floors and stained ceilings months after the leak started. Before you buy: Press the sidewalls and walk the floor; look at every seam and seal.
Roof, leaks and body lessons · Seals and leaks guide
Other: 1 complaint
Doors, windows, steps and lights: 1 complaint
What a tech checks: Mostly adjustments and wear: steps that stop halfway on a bad switch, doors out of alignment after a slide shifted, exterior lights with a corroded ground. Before you buy: Every door, lock, window and light.
What owners reported to NHTSA
04/22/2013, VISIBILITY/WIPER: THE DRIVER SIDE REAR VIEW MIRROR IS USELESS DURING MOST OF THE DAYTIME DRIVING. IT REFLEX OBJECTS FROM THE RIGHT SIDE OF THE VEHICLE AND THE DRIVER CANNOT SEE WHAT IS COMING UP ON THE LEFT. THE COMPANY IS AWARE OF IT AND WILL NOT DO ANYTHING ABOUT IT. *TR
04/22/2013, STRUCTURE,EQUIPMENT: THE CABINETS OVER THE DRIVER AND PASSENGER SIDE OF THE MOTOR HOME (RV). DROPPED APPROXIMATELY 6 TO12 INCHES. FEW SCREWS ON THE LEFT SIDE HELD IT FROM DROPPING ALL THE WAY DOWN. IT APPEARS THAT THE LARGE SCREWS MISSED THE SUPPORTS AND THE SMALL SCREWS NEVER MADE IT TO THE SUPPORT. NOTHING IS KEPT IN THESE CABINETS EXCEPT A FEW ITEM THAT WERE PUT IN AT THE FACTORY. (NO TV) *TR
Looking at a 2011 Fleetwood Bounder?
The Buyer's Check walks you through it on your phone: what to ask, the outside walk-around, water damage, every system on every power source, with the recalls above built in. You get a report that says what's a walk-away and what to negotiate on.
Checked against NHTSA 2026-10-23. Recall repairs are free at an authorized dealer. Complaints are owner reports to NHTSA and are not verified.