2006 Fleetwood Excursion problems: recalls, complaints and what to check
NHTSA has 5 recalls and 7 owner complaints on file for the 2006 Fleetwood Excursion. Here is what they are, what a technician checks for each kind of fault, and how to look one over before you buy it.
Other: 4 recalls, 4 complaints
Recall 06V032000 (08/02/2006): EQUIPMENT:OTHER:LABELS
CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567, "CERTIFICATION." THE FEDERAL CERTIFICATION TAG MAY BE PRINTED WITH THE INCORRECT GROSS VEHICLE WEIGHT RATING (GVWR) WEIGHT VALUE OF 31,000 POUNDS. THE CORRECT GVWR WEIGHT VALUE IS 28,000 POUNDS. THE SAME WEIGHT ERROR MAY OCCUR ON THE CARGO CARRYING CAPACITY TAG.
Fix: DEALERS WILL SEND REPLACEMENT LABELS ALONG WITH INSTRUCTIONS. IF NECESSARY, DEALERS WILL CHANGE CERTAIN FRONT SUSPENSION COMPONENTS AND CERTIFY THE CHASSIS FOR THE 31,000 POUNDS GVWR WEIGHT VALUE. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.
Recall 06V055000 (23/02/2006): EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
ON CERTAIN MOTOR HOMES EQUIPPED WITH KWIKEE BRAND ELECTRIC ENTRY STEP BUILT WITH A CONTROL UNIT MANUFACTURED BY AMERICAN TECHNOLOGIES, MAY DEVELOP AN ELECTRICAL SHORT DURING COLD WEATHER, ALLOWING FOR THE POTENTIAL OF THE PLASTIC CASE TO IGNITE.
Fix: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE ALL AMERICAN TECHNOLOGIES CONTROLS ASSOCIATED WITH THE KWIKEE BRAND ELECTRIC ENTRY STEP FREE OF CHARGE. THE RECALL BEGAN ON MARCH 17, 2006. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.
Recall 08V320000 (15/07/2008): EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
FLEETWOOD IS RECALLING 70,101 MY 2003-2007 SOUTHWIND, PACE ARROW, BOUNDER, FLAIR, STORM, FIESTA, TERRA GAS CLASS A MOTOR HOMES; BOUNDER, DISCOVERY, PROVIDENCE, EXCURSION, EXPEDITION, REVOLUTION, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION DIESEL CLASS A MOTOR HOMES; JAMBOREE TIOGA CLASS C MOTOR HOMES; AND PROWLER, WILDERNESS, TERRY, MALLARD, PIONEER, PRIDE AND TRIUMPH CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATORS MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Fix: FLEETWOOD IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.
Recall 05V333000 (27/07/2005): EQUIPMENT:OTHER:LABELS
CERTAIN DIESEL CLASS A MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567, "CERTIFICATION." THE MANUFACTURERS' TOW HITCH RECEIVER INFORMATION LABEL WAS PRINTED WITH THE INCORRECT WEIGHT CARRYING CAPACITY VALUE AND THE INCORRECT TONGUE WEIGHT VALUE.
Fix: FLEETWOOD WILL MAIL OWNERS THE CORRECT TOW HITCH RECEIVER WEIGHT INFORMATION LABEL. IF OWNERS DO NOT FEEL COMFORTABLE INSTALLING THE LABEL, DEALERS WILL INSTALL THE LABEL FOR THEM. THE RECALL BEGAN AUGUST 4, 2005. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.
12 volt and 120 volt electrical: 1 recall, 1 complaint
Recall 09V056000 (18/02/2009): ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES
FLEETWOOD IS RECALLING 3,782 MY 2006-2009 PROVIDENCE, EXCURSION, EXPEDITION, DISCOVERY AND BOULDER DIESEL MOTOR HOMES. THE BATTERY CABLE IS ROUTED TOO CLOSE TO A SHARP EDGE LOCATED ON TOP OF A SHELF INSTALLED OVER THE DRIVESHAFT.
Fix: DEALERS WILL RE-ROUTE THE CABLE AWAY FROM THE SHARP EDGE LOCATION. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE RECALL BEGAN ON MAY, 26 2009. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.
What a tech checks: Voltage drop, grounds, the converter and the transfer switch. Melted shore-cord plugs and bad grounds cause most of the electrical complaints techs actually see. Before you buy: Battery at rest, converter output on shore power, GFCI test, every outlet.
12 V electrical lessons · 120 V and generator lessons · Wiring diagrams
Doors, windows, steps and lights: 5 complaints
What a tech checks: Mostly adjustments and wear: steps that stop halfway on a bad switch, doors out of alignment after a slide shifted, exterior lights with a corroded ground. Before you buy: Every door, lock, window and light.
Structure, roof and leaks: 1 complaint
What a tech checks: Roof sealant, seams, window and slide seals, and the frame. Water intrusion shows up as delamination, soft floors and stained ceilings months after the leak started. Before you buy: Press the sidewalls and walk the floor; look at every seam and seal.
Roof, leaks and body lessons · Seals and leaks guide
Motorhome chassis: 1 complaint
What a tech checks: The chassis (Ford, Freightliner, Mercedes, Ram) is serviced by the chassis maker's dealer, not the RV shop. RV techs handle the house, not the drivetrain. Before you buy: Chassis recalls are fixed free at the chassis maker's dealer.
Axles, brakes, suspension and hitch: 1 complaint
What a tech checks: Bearings, brake magnets, worn shackle bolts and bent axles. A trailer that wears tires on the inside edge or pulls to one side usually has an axle or suspension problem. Before you buy: Bolts tight, springs not flat, brakes apply with the breakaway pin pulled.
Chassis and towing lessons · Trailer guide
What owners reported to NHTSA
12/29/2006, ELECTRICAL SYSTEM: WHY DOESN'T FLEETWOOD SAFETY RECALL # 06004 SHOW UP IN THE NHTSA DATABSE. ISN'T IT THE SAME KWIKEE STEP & SIMILAR WIRING PROBLEM AS FLEETWOOD'S RECALL # 60220 FOR SIMILAR VEHICLES. WHILE THIS RECALL IS CALLED AN UPGRADE NOTING THAT "THE WIRE IS NOT INTENDED TO CARRY THIS AMOUNT OF ELECTRICAL ENERGY & MAY BURN THROUGH AND MELT" , #60220 REGARDS THIS AS A SAFETY HAZARD.
08/15/2012, VISIBILITY,STRUCTURE,EQUIPMENT: BOUGHT A 2006 FLEETWOOD EXCURSION NEW IN 2007 WITH IN 3 YEARS SEVERAL WINDOWS LOST THEIR SEAL. TOTAL OF 5 SO FAR INCLUDING WINDOW BY DRIVER'S SEAT,CAUSING PROBLEMS WITH VISION. I CONTACTED FLEETWOOD WHO SAID THEY HAD NO LIABILITY. I CONTACTED A GLASS COMPANY WHO SAID THAT SHOULD NOT HAVE OCCURRED . I HAVE OWNED CARS 40 TO 50 YEARS OLD WHICH DID NOT HAVE THIS PROBLEM . IS THERE NOT A STANDARD FOR GLASS INSTALLED IN MO
07/28/2008, EQUIPMENT: TL*THE CONTACT OWNS A 2006 FLEETWOOD EXCURSION. THE MOTOR HOME WAS JACKED UP AND LEVELED. WHEN THE CONTACT PRESSED THE BUTTON TO RETRACT THE JACKS, ALL BUT ONE RETRACTED BECAUSE IT WAS HUNG UP. HE CALLED ROADSIDE ASSISTANCE AFTER TWO HOURS OF ATTEMPTING TO GET IT BACK IN AND HE EVEN USED HYDRAULIC PRESSURE TO ASSIST. HE IS CURRENTLY WAITING FOR ANOTHER JACK TO BE MADE FOR THE MOTOR HOME. THE CURRENT AND FAILURE
07/02/2014, VISIBILITY: TL* THE CONTACT OWNS A 2006 FLEETWOOD EXCURSION. THE CONTACT STATED THAT THE DUAL PANE WINDOW BECAME FOGGED AND IMPAIRED HIS VISION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 45,000.
05/14/2014, VISIBILITY,VISIBILITY/WIPER: THE WINDOWS STARTED FOGGY UP IN MY RV AND HAVE STEADY GOTTEN WORSE, ESPECIALLY THE DRIVERS WINDOW. AT NIGHT IT'S ALMOST IMPOSSIBLE TO SEE OUT OF THE SIDE MIRROR DUE TO THE "FOGGING" OF THE WINDOW. FROM THE MANY COMPLAINTS I HAVE READ FROM OTHER RVERS, FLEETWOOD SEEMS TO HAVE USED INFERIOR WINDOWS WHEN THE RV WAS MANUFACTURED. I HAVE NEVER RECEIVED A RECALL ON THESE WINDOWS FROM FLEETWOOD FOR REPLACEMENT DUE TO THE
02/25/2008, LATCHES/LOCKS/LINKAGES,EQUIPMENT: SLIDE TRAVEL LOCKS FAILED TO ENGAGE. *TR
Looking at a 2006 Fleetwood Excursion?
The Buyer's Check walks you through it on your phone: what to ask, the outside walk-around, water damage, every system on every power source, with the recalls above built in. You get a report that says what's a walk-away and what to negotiate on.
Checked against NHTSA 2026-10-23. Recall repairs are free at an authorized dealer. Complaints are owner reports to NHTSA and are not verified.