2006 Fleetwood Flair problems: recalls, complaints and what to check
NHTSA has 5 recalls and 3 owner complaints on file for the 2006 Fleetwood Flair. Here is what they are, what a technician checks for each kind of fault, and how to look one over before you buy it.
Other: 2 recalls, 1 complaint
Recall 06V055000 (23/02/2006): EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
ON CERTAIN MOTOR HOMES EQUIPPED WITH KWIKEE BRAND ELECTRIC ENTRY STEP BUILT WITH A CONTROL UNIT MANUFACTURED BY AMERICAN TECHNOLOGIES, MAY DEVELOP AN ELECTRICAL SHORT DURING COLD WEATHER, ALLOWING FOR THE POTENTIAL OF THE PLASTIC CASE TO IGNITE.
Fix: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE ALL AMERICAN TECHNOLOGIES CONTROLS ASSOCIATED WITH THE KWIKEE BRAND ELECTRIC ENTRY STEP FREE OF CHARGE. THE RECALL BEGAN ON MARCH 17, 2006. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.
Recall 08V320000 (15/07/2008): EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
FLEETWOOD IS RECALLING 70,101 MY 2003-2007 SOUTHWIND, PACE ARROW, BOUNDER, FLAIR, STORM, FIESTA, TERRA GAS CLASS A MOTOR HOMES; BOUNDER, DISCOVERY, PROVIDENCE, EXCURSION, EXPEDITION, REVOLUTION, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION DIESEL CLASS A MOTOR HOMES; JAMBOREE TIOGA CLASS C MOTOR HOMES; AND PROWLER, WILDERNESS, TERRY, MALLARD, PIONEER, PRIDE AND TRIUMPH CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATORS MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Fix: FLEETWOOD IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.
Motorhome chassis: 2 recalls, 1 complaint
Recall 06V218000 (19/06/2006): STEERING
ON CERTAIN CLASS A MOTOR HOMES BUILT ON WORKHORSE CHASSIS MAY HAVE BEEN EQUIPPED WITH INCORRECT STEERING INTERMEDIATE SHAFTS. THE SPLINE CAN STRIP WHILE THE STEERING WHEEL IS BEING TURNED.
Fix: WORKHORSE IS CONDUCTING THIS RECALL (PLEASE SEE 06V148000) AND WILL INSPECT AND, IF NECESSARY, REPLACE THE STEERING INTERMEDIATE SHAFTS. OWNERS MAY CONTACT WORKHORSE AT 1-877-294-6773 OR FLEETWOOD AT 1-800-322-8216.
Recall 06V388000 (04/10/2006): ENGINE AND ENGINE COOLING
ON CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH GENERAL MOTORS 8.1L V8 ENGINES, IMPROPER HARDENING DURING THE HEAT TREATMENT PROCESS CAN CAUSE THE FUEL RAIL PULSE DAMPER RETAINER CLIP TO FRACTURE, RESULTING IN INADEQUATE RETENTION OF THE DAMPER. IF THE DAMPER BECOMES LOOSE, FUEL COULD BE PUMPED BY THE FUEL PUMP INTO THE UNDER HOOD AREA.
Fix: WORKHORSE IS HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN (PLEASE SEE 06V225). DEALERS WILL REPLACE THE FUEL RAIL PULSE DAMPER RETAINER CLIPS ON THESE ENGINES FREE OF CHARGE. OWNERS MAY CONTACT WORKHORSE AT 877-294-6773 OR FLEETWOOD AT 1-800-322-8216.
What a tech checks: The chassis (Ford, Freightliner, Mercedes, Ram) is serviced by the chassis maker's dealer, not the RV shop. RV techs handle the house, not the drivetrain. Before you buy: Chassis recalls are fixed free at the chassis maker's dealer.
Axles, brakes, suspension and hitch: 1 recall, 2 complaints
Recall 09V198000 (02/06/2009): SERVICE BRAKES, AIR
FLEETWOOD IS RECALLING 509 MY 2001-2008 CLASS A MOTOR HOMES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.
Fix: DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. WORKHORSE IS HANDLING THE REMEDY FOR THIS CAMPAIGN PLEASE SEE 09V-110. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731. WORKHORSE WILL CONDUCT THE OWNER AND DEALER NOTIFICATION.
What a tech checks: Bearings, brake magnets, worn shackle bolts and bent axles. A trailer that wears tires on the inside edge or pulls to one side usually has an axle or suspension problem. Before you buy: Bolts tight, springs not flat, brakes apply with the breakaway pin pulled.
Chassis and towing lessons · Trailer guide
Structure, roof and leaks: 1 complaint
What a tech checks: Roof sealant, seams, window and slide seals, and the frame. Water intrusion shows up as delamination, soft floors and stained ceilings months after the leak started. Before you buy: Press the sidewalls and walk the floor; look at every seam and seal.
Roof, leaks and body lessons · Seals and leaks guide
What owners reported to NHTSA
07/26/2011, TRAILER HITCHES: TL* THE CONTACT OWNS A 2006 FLEETWOOD FLAIR. THE CONTACT STATED THAT WHILE DRIVING 10 MPH AND ENTERING AN INTERSECTION, THE WELDS BETWEEN THE HITCH RECEIVER BOX AND THE FRAME BROKE APART. THE CONTACT WAS TOWING ANOTHER VEHICLE DURING THE FAILURE AND AS A RESULT, THE VEHICLE BEING TOWED DETACHED AND ROLLED ACROSS THE ROADWAY BEFORE CRASHING. NO INJURIES WERE REPORTED. THE VEHICLE WAS DRIVEN HOME AND WAS NOT TAKEN TO H
07/05/2007, POWER TRAIN,STRUCTURE: TOOK THE MOTOR HOME FOR REPAIR OF THE FRAME DUE TO THE FLOOR SAGGING ON 11/2006. AT THE TIME THEY WELDED THE FRAME TO SUPPORT THE FLOOR. THEN , THERE WAS A REAR AXLE NOISE ,AND I TOOK IT IN TO GET REPAIRED UNDER WARRANTY ON 6/2007. THEY INFORMED AT ME THAT TIME THAT THE FRAME HAD BEEN EXTENDED. THEY TOLD ME TO CONTACT THE RV DEALER TO HAVE THEM CHECK IT. ON 7/5/2007 I RECEIVED A PHONE CALL FROM THEMFORD DEALERS
06/28/2010, SERVICE BRAKES, HYDRAULIC: TL* THE CONTACT OWNS A 2006 FLEETWOOD FLAIR RV. WHILE BRAKING FROM 45 MPH, THE BRAKES WOULD NOT ENGAGE. THE CONTACT HAD PREVIOUSLY RECEIVED NOTIFICATION OF NHTSA RECALL CAMPAIGN ID NUMBER: 09V198000 (SERVICE BRAKES, AIR) AND TOOK THE VEHICLE TO THE DEALER FOR REPAIRS. THE DEALER ADVISED THE BRAKES WERE NOT DEFECTIVE ENOUGH FOR REPAIRS. THE CYLINDERS WERE LUBRICATED BY THE DEALER YET NO FURTHER REPAIRS WERE MADE TO TH
Looking at a 2006 Fleetwood Flair?
The Buyer's Check walks you through it on your phone: what to ask, the outside walk-around, water damage, every system on every power source, with the recalls above built in. You get a report that says what's a walk-away and what to negotiate on.
Checked against NHTSA 2026-10-23. Recall repairs are free at an authorized dealer. Complaints are owner reports to NHTSA and are not verified.