2016 Forest River Evo problems: recalls, complaints and what to check
NHTSA has 2 recalls and 2 owner complaints on file for the 2016 Forest River Evo, including 1 fire. Here is what they are, what a technician checks for each kind of fault, and how to look one over before you buy it.
Axles, brakes, suspension and hitch: 1 recall, 1 complaint
Recall 15V359000 (09/06/2015): SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY
Forest River, Inc. (Forest River) is recalling certain model year 2016 Evo, Salem, Sandstorm, Shockwave, Stealth, Wildwood, Cherokee Grey Wolf, Wildcat Maxx, Vibe, R-Pod, and Surveyor trailers. In the affected trailers, the studs that are used to attach the wheels to the axle hubs may break.
Fix: Forest River will notify owners, and dealers will inspect and replace any affected wheel hub, free of charge. The recall began on June 25, 2015. Owners may contact Forest River customer service at 1-909-873-3777. Forest River's number for this recall is 51-05142015-0037.
What a tech checks: Bearings, brake magnets, worn shackle bolts and bent axles. A trailer that wears tires on the inside edge or pulls to one side usually has an axle or suspension problem. Before you buy: Bolts tight, springs not flat, brakes apply with the breakaway pin pulled.
Chassis and towing lessons · Trailer guide
Other: 1 recall
Recall 15V831000 (10/12/2015): EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
Forest River, Inc. (Forest River) is recalling certain model year 2016 Evo, Salem, Sandstorm, Shockwave, Stealth, and Wildwood recreational trailers. The affected vehicles were mistakenly not equipped with a carbon monoxide detector to warn occupants of elevated levels of carbon monoxide.
Fix: Forest River will notify owners, and dealers will remove the existing Liquid Propane (L.P.) Detector and install a combination L.P./carbon monoxide detector, free of charge. The recall began on January 27, 2016. Owners may contact Forest River customer service at 1-909-873-3777, extension 53. Forest River's number for this recall is 51-12072015-0119.
Structure, roof and leaks: 2 complaints
What a tech checks: Roof sealant, seams, window and slide seals, and the frame. Water intrusion shows up as delamination, soft floors and stained ceilings months after the leak started. Before you buy: Press the sidewalls and walk the floor; look at every seam and seal.
Roof, leaks and body lessons · Seals and leaks guide
What owners reported to NHTSA
09/19/2019, SUSPENSION,STRUCTURE: TL* THE CONTACT OWNS A 2020 FOREST RIVER EVO T2360 TRAVEL TRAILER (NA) ATTACHED TO A 1996 FORD F-150. WHILE DRIVING APPROXIMATELY 55 MPH, THE TRAVEL TRAILER CAUGHT ON FIRE NEAR THE DRIVER'S SIDE WHEEL. THE CONTACT PULLED OVER AND EXTINGUISHED THE FIRE WITH BOTTLES OF WATER. THE TRAVEL TRAILER WAS TAKEN TO THE NEAREST CAMPGROUND WHERE A CERTIFIED MECHANIC INSPECTED THE VEHICLE AND STATED THAT THE FIRE WAS NEAR THE REA
08/21/2019, STRUCTURE: TL* THE CONTACT OWNS A 2016 FOREST RIVER EVO 19RB. THE CONTACT STATED THAT HER GRANDDAUGHTER WAS OUTSIDE OF THE MOTOR CARRIER AND BURNED HER HAND (3 FINGERS BLISTERED) WHEN SHE TOUCHED THE HOT WATER HEATER GRATE. THE WATER HEATER GRATE WAS LOCATED NEXT TO THE TRAILER DOOR AND THERE WAS NO INDICATION THAT IT WAS HOT AND DANGEROUS TO TOUCH. NO INJURIES WERE SUSTAINED DUE TO THE BURN. THE DEALER AND MANUFACTURER WERE NO
Looking at a 2016 Forest River Evo?
The Buyer's Check walks you through it on your phone: what to ask, the outside walk-around, water damage, every system on every power source, with the recalls above built in. You get a report that says what's a walk-away and what to negotiate on.
Checked against NHTSA 2026-10-23. Recall repairs are free at an authorized dealer. Complaints are owner reports to NHTSA and are not verified.