2019 Forest River Sunseeker problems: recalls, complaints and what to check
NHTSA has 1 recall and 3 owner complaints on file for the 2019 Forest River Sunseeker. Here is what they are, what a technician checks for each kind of fault, and how to look one over before you buy it.
Axles, brakes, suspension and hitch: 1 recall, 1 complaint
Recall 18V357000 (01/06/2018): POWER TRAIN:AXLE ASSEMBLY
Forest River, Inc. (Forest River) is recalling certain 2019 Forest River Forester and Sunseeker and Coachmen Leprechaun and Freelander motorhomes. The U-Bolts that secure the rear differential may not have been properly tightened, causing them to loosen over time and allowing the rear axles to shift.
Fix: Forest River has notified owners, and dealers will inspect the U-Bolts and properly tighten or replace the U-Bolts, as necessary, free of charge. The recall began on June 6, 2018. Owners may contact Forest River customer service for Sunseeker and Forester vehicles at 1-574-206-7600, or Coachmen customer service for Freelander and Leprechaun vehicles at 1-574-825-8602. Forest River's number for this recall is 105-0749.
What a tech checks: Bearings, brake magnets, worn shackle bolts and bent axles. A trailer that wears tires on the inside edge or pulls to one side usually has an axle or suspension problem. Before you buy: Bolts tight, springs not flat, brakes apply with the breakaway pin pulled.
Chassis and towing lessons · Trailer guide
Structure, roof and leaks: 2 complaints
What a tech checks: Roof sealant, seams, window and slide seals, and the frame. Water intrusion shows up as delamination, soft floors and stained ceilings months after the leak started. Before you buy: Press the sidewalls and walk the floor; look at every seam and seal.
Roof, leaks and body lessons · Seals and leaks guide
Other: 2 complaints
What owners reported to NHTSA
09/25/2025, SUSPENSION,STRUCTURE: Improper welding on chassis frame extensions. 6 individual points for welds and insufficient and pose an extreme safety risk. National General Insurance sent out an inspector and I have a report denying my claim under insurance and calling this a manufacturer default (Chevy Chassis, Forest River Sunseeker C Class Motorhome) Reported to Chevrolet 9/25 and the say because it's out of warranty, I can submit a claim t
07/19/2024, UNKNOWN OR OTHER,EQUIPMENT: The mounting bracket for the leveling system hydraulic pump dislodged from the frame - the weld broke. The hydralic reservoir tank falls to the pavement and can cause a serious accident and/or fire. I see Jayco issued a recall for the exact same issue (Bulletin #(s): 20V-780 US Units 2021-009 CN Units). Forest River has not. There are other discussions of this problem on the Forest River forums - [XXX] [XXX] T
04/12/2022, STRUCTURE: The contact owns a 2019 Forest River Sunseeker RV. The contact stated that while the vehicle was in for routine service it was discovered that the rooftop solar panel was no longer attached to the vehicle. The contact was informed by the mechanic that the panel was missing and possibly detached while the vehicle was being driven on the highway. The cause of the failure was not determined. The manufacturer and local d
Looking at a 2019 Forest River Sunseeker?
The Buyer's Check walks you through it on your phone: what to ask, the outside walk-around, water damage, every system on every power source, with the recalls above built in. You get a report that says what's a walk-away and what to negotiate on.
Checked against NHTSA 2026-10-23. Recall repairs are free at an authorized dealer. Complaints are owner reports to NHTSA and are not verified.