2019 Grand Design Momentum problems: recalls, complaints and what to check
NHTSA has 2 recalls and 15 owner complaints on file for the 2019 Grand Design Momentum. Here is what they are, what a technician checks for each kind of fault, and how to look one over before you buy it.
Other: 11 complaints
Structure, roof and leaks: 9 complaints
What a tech checks: Roof sealant, seams, window and slide seals, and the frame. Water intrusion shows up as delamination, soft floors and stained ceilings months after the leak started. Before you buy: Press the sidewalls and walk the floor; look at every seam and seal.
Roof, leaks and body lessons · Seals and leaks guide
Refrigerators: 1 recall
Recall 22V038000 (28/01/2022): EQUIPMENT:APPLIANCE:REFRIGERATOR
Grand Design RV, LLC (Grand Design) is recalling certain 2013-2021 Momentum, Solitude, and Reflection recreational vehicles. A 110-volt wire in the refrigerator cabinet may be improperly secured, which could result in the wire contacting the refrigerator cooling unit, causing an electrical arc.
Fix: Dealers will inspect and replace any damaged wiring, and properly secure the wires, free of charge. Owner notification letters were mailed on February 21, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910026.
What a tech checks: On absorption fridges the big failure is the cooling unit leaking ammonia (yellow residue, a sharp smell) and boards or igniters on the gas side. Compressor fridges fail on the 12 V supply more than the compressor. Before you buy: Look at the back through the outside vent for yellow powder; run it on both power sources.
Refrigerator lessons · Refrigerator 3D lab
LP gas and gas appliances: 1 recall
Recall 21V393000 (26/05/2021): EQUIPMENT:RECREATIONAL VEHICLE/TRAILER:LPG SYSTEMS
Grand Design RV, LLC (Grand Design) is recalling certain 2016-2021 Imagine, Transcend, and Momentum travel trailers. The LP regulator that controls the LP gas pressure may fail, allowing excessive gas pressure that causes the appliance flame to increase.
Fix: Dealers will replace the LP regulator, free of charge. Owner notification letters were mailed June 24, 2021. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910023.
What a tech checks: Regulator, lines and fittings, then the appliances: furnace, water heater, range. A proper pressure-drop leak test is the first thing a tech does on an LP complaint. Before you buy: Smell for gas with the tank open; have a shop do the leak test.
LP and furnace lessons · Furnace guide · Furnace 3D lab · Water heater 3D lab
12 volt and 120 volt electrical: 3 complaints
What a tech checks: Voltage drop, grounds, the converter and the transfer switch. Melted shore-cord plugs and bad grounds cause most of the electrical complaints techs actually see. Before you buy: Battery at rest, converter output on shore power, GFCI test, every outlet.
12 V electrical lessons · 120 V and generator lessons · Wiring diagrams
Axles, brakes, suspension and hitch: 3 complaints
What a tech checks: Bearings, brake magnets, worn shackle bolts and bent axles. A trailer that wears tires on the inside edge or pulls to one side usually has an axle or suspension problem. Before you buy: Bolts tight, springs not flat, brakes apply with the breakaway pin pulled.
Chassis and towing lessons · Trailer guide
Doors, windows, steps and lights: 2 complaints
What a tech checks: Mostly adjustments and wear: steps that stop halfway on a bad switch, doors out of alignment after a slide shifted, exterior lights with a corroded ground. Before you buy: Every door, lock, window and light.
What owners reported to NHTSA
12/26/2022, FUEL/PROPULSION SYSTEM: Our RV completly filled with the smell of propane when manually switching propane tanks while the furnance was running. The smell was coming from furnance vents. We checked the stove and the flame on the burner was unusually several inches higher in height. There no smell of propane in the exterior compartments or vents and isolated to the inside of the RV. All windows were opened and the furnance turned off to vent
12/03/2024, SUSPENSION,LATCHES/LOCKS/LINKAGES: The contact owns a 2019 Grand Design RV. The contact stated while driving at an undisclosed speed, the RV the front and rear doors inadvertently opened. The RV was taken to the dealer but was not diagnosed; however, the dealer informed the contact that the doors had been repaired. The contact stated while driving at an undisclosed speed, the rear tires blew out. There was no warning light illuminated. The contact pul
11/26/2024, STRUCTURE,UNKNOWN OR OTHER: Frame failure on fifth wheel deck. Noticed when hooking RV to tow vehicle that the pin box would move upward roughly 1 inch. Also when hitched to tow vehicle would notice that all cabinets in front bedroom would move to the point of damaging walls and causing the doors to bind and hit the ceiling. Once I learned of many other Grand Design RV owners having this same problem, I removed the front skin to expose the fram
11/26/2018, WHEELS: DRIVING DOWN HIGHWAY I-10 FROM NEW BRAUNFELS, TEXAS TO HOUSTON, TEXAS. THE FIRST TIRE BLEW OUT ON PASSENGER SIDE OF OUR NEW FIFTH WHEEL RV.
11/11/2024, UNKNOWN OR OTHER: Welds on the frame where the fifth wheel overhang attaches to the main frame have broke allowing the kingpin to raise up off of the front upright. This means that the kingpin overhang is only attached at the rear upright making the RV unsafe to tow.
11/10/2025, STRUCTURE: The contact owns a 2019 Grand Design Momentum 49M hitched to a 2017 Ford F-350. The contact stated that while the RV was parked, the driver’s side bedroom slide-out failed to extend as intended. The RV was taken to a dealer, where the failure was linked to frame flex. The contact was informed that there were four cracks in the frame of the RV. The RV was not diagnosed. The contact stated that the manufacturer was not
Looking at a 2019 Grand Design Momentum?
The Buyer's Check walks you through it on your phone: what to ask, the outside walk-around, water damage, every system on every power source, with the recalls above built in. You get a report that says what's a walk-away and what to negotiate on.
Checked against NHTSA 2026-10-23. Recall repairs are free at an authorized dealer. Complaints are owner reports to NHTSA and are not verified.