2014 Grand Design Reflection problems: recalls, complaints and what to check
NHTSA has 2 recalls and 1 owner complaint on file for the 2014 Grand Design Reflection. Here is what they are, what a technician checks for each kind of fault, and how to look one over before you buy it.
Axles, brakes, suspension and hitch: 1 recall, 1 complaint
Recall 15V518000 (14/08/2015): SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY
Grand Design RV, LLC (Grand Design) is recalling certain model year 2014-2016 Reflection fifth-wheel trailers manufactured September 5, 2013, to June 30, 2015. The affected vehicles may have been manufactured with axles rated to 5200 lbs. instead of 6000 lbs. as designed and as listed on the Certification Label. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Fix: Grand Design will notify owners, and dealers will inspect the trailers and will replace any axle that is only rated to 5200 lbs. with an axle rated to 6000 lbs., free of charge. The recall began on September 10, 2015. Owners may contact Grand Design customer service at 1-574-825-8000 ext. 2015. Grand Design's number for this recall is 910004.
What a tech checks: Bearings, brake magnets, worn shackle bolts and bent axles. A trailer that wears tires on the inside edge or pulls to one side usually has an axle or suspension problem. Before you buy: Bolts tight, springs not flat, brakes apply with the breakaway pin pulled.
Chassis and towing lessons · Trailer guide
Refrigerators: 1 recall
Recall 22V038000 (28/01/2022): EQUIPMENT:APPLIANCE:REFRIGERATOR
Grand Design RV, LLC (Grand Design) is recalling certain 2013-2021 Momentum, Solitude, and Reflection recreational vehicles. A 110-volt wire in the refrigerator cabinet may be improperly secured, which could result in the wire contacting the refrigerator cooling unit, causing an electrical arc.
Fix: Dealers will inspect and replace any damaged wiring, and properly secure the wires, free of charge. Owner notification letters were mailed on February 21, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910026.
What a tech checks: On absorption fridges the big failure is the cooling unit leaking ammonia (yellow residue, a sharp smell) and boards or igniters on the gas side. Compressor fridges fail on the 12 V supply more than the compressor. Before you buy: Look at the back through the outside vent for yellow powder; run it on both power sources.
Refrigerator lessons · Refrigerator 3D lab
What owners reported to NHTSA
01/19/2017, SERVICE BRAKES: GREASE SEALS ON INNER HUB AND CAP ON OUTER HUB LEAKED GREASE INTO BRAKE SYSTEM AND CONTAMINATED THE BRAKES. COULD BE THE GREASE WAS TOO THIN, OVER PACKED OR GREASE SEALS DEFECTIVE. I HAVE CLEANED AND RESEALED MY BRAKES TWICE. LIPPERT WHO SUPPLIES THE AXLE AND BRAKE ASSEMBLIES TO GRAND DESIGN SENT ME NEW GREASE SEALS ONCE BUT DID NOT AGREE TO PAY FOR MY TIME AND OTHER SUPPLIES. I WAS ABLE TO CATCH IT QUICK ENOUGH
Looking at a 2014 Grand Design Reflection?
The Buyer's Check walks you through it on your phone: what to ask, the outside walk-around, water damage, every system on every power source, with the recalls above built in. You get a report that says what's a walk-away and what to negotiate on.
Checked against NHTSA 2026-10-23. Recall repairs are free at an authorized dealer. Complaints are owner reports to NHTSA and are not verified.