2015 Grand Design Reflection problems: recalls, complaints and what to check
NHTSA has 4 recalls and 16 owner complaints on file for the 2015 Grand Design Reflection, including 1 fire. Here is what they are, what a technician checks for each kind of fault, and how to look one over before you buy it.
Axles, brakes, suspension and hitch: 2 recalls, 14 complaints
Recall 15V518000 (14/08/2015): SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY
Grand Design RV, LLC (Grand Design) is recalling certain model year 2014-2016 Reflection fifth-wheel trailers manufactured September 5, 2013, to June 30, 2015. The affected vehicles may have been manufactured with axles rated to 5200 lbs. instead of 6000 lbs. as designed and as listed on the Certification Label. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Fix: Grand Design will notify owners, and dealers will inspect the trailers and will replace any axle that is only rated to 5200 lbs. with an axle rated to 6000 lbs., free of charge. The recall began on September 10, 2015. Owners may contact Grand Design customer service at 1-574-825-8000 ext. 2015. Grand Design's number for this recall is 910004.
Recall 15V212000 (10/04/2015): SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY
Grand Design RV, LLC (Grand Design) is recalling certain model year 2015-2016 Reflection 303RLS, 308BHTS and 313RLTS, model 2016 Solitude 375RE trailers manufactured March 12, 2015, to April 6, 2015. In the affected trailers, the studs that are used to attach the wheels to the axle hubs may break.
Fix: Grand Design has notified owners, and dealers will replace any affected wheel hub, free of charge. The recall began on April 14, 2015. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910003.
What a tech checks: Bearings, brake magnets, worn shackle bolts and bent axles. A trailer that wears tires on the inside edge or pulls to one side usually has an axle or suspension problem. Before you buy: Bolts tight, springs not flat, brakes apply with the breakaway pin pulled.
Chassis and towing lessons · Trailer guide
Other: 1 recall, 2 complaints
Recall 16V717000 (07/10/2016): EQUIPMENT:OTHER:LABELS
Grand Design RV, LLC (Grand Design) is recalling certain model year 2015-2017 Reflection recreational trailers, model 357BHS and 367BHS, manufactured November 12, 2014, to September 22, 2016. The affected vehicles have an incorrect Gross Axle Weight Rating (GAWR) on the Federal Certification Label, stating a GAWR of 7,000 lbs when the actual GAWR is 6,400 lbs. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Fix: Grand Design will notify owners, and dealers will install a corrected Federal Certification Label, free of charge. Owners will also have the option to replace the Certification Label themselves, free of charge. The recall began on October 28, 2016. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910007.
Refrigerators: 1 recall
Recall 22V038000 (28/01/2022): EQUIPMENT:APPLIANCE:REFRIGERATOR
Grand Design RV, LLC (Grand Design) is recalling certain 2013-2021 Momentum, Solitude, and Reflection recreational vehicles. A 110-volt wire in the refrigerator cabinet may be improperly secured, which could result in the wire contacting the refrigerator cooling unit, causing an electrical arc.
Fix: Dealers will inspect and replace any damaged wiring, and properly secure the wires, free of charge. Owner notification letters were mailed on February 21, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910026.
What a tech checks: On absorption fridges the big failure is the cooling unit leaking ammonia (yellow residue, a sharp smell) and boards or igniters on the gas side. Compressor fridges fail on the 12 V supply more than the compressor. Before you buy: Look at the back through the outside vent for yellow powder; run it on both power sources.
Refrigerator lessons · Refrigerator 3D lab
Tires: 1 complaint
What a tech checks: Age, load range and pressure. RV tires age out before they wear out, and an underrated tire on a heavy trailer is a blowout waiting to happen. Before you buy: Read the DOT date and the load range on the sidewall.
Chassis, towing and tires lessons · Trailer guide
What owners reported to NHTSA
11/01/2016, SERVICE BRAKES: GREASE SEALS FAILING CAUSING AXLE GREASE TO COVER WHEELS AND BRAKE PADS. DEALER HAS REPLACED BOTH SETS OF SEALS ON BOTH SIDES OF BOTH TANDEM AXLES DUE TO THIS ISSUE. ONE SIDE WAS REPLACED IN JAN 2016, THE OTHER SIDE WAS REPLACED IN SEPT 2016.
09/10/2018, SUSPENSION: I PURCHASED THIS RV NEW. I LOST A WHEEL BEARING BECAUSE OF A BAD WHEEL HUB. I WAS ABLE TO REPAIR THE AXLE ENOUGH TO STILL USE. IN 2017 ON MY WAY TO ARIZONA I LOST THIS SAME WHEEL BEARING AGAIN AND WAS ABLE TO REPAIR IT ONCE AGAIN TO CONTINUE MY TRIP. AFTER RETURNING HOME LAST SPRING I DECIDED TO REPLACE THIS AXLE. UPON REMOVING THE AXLE I DISCOVERED THAT THE AXLES ON THIS RV ARE 4400# AXLES. MY PAPERWORK ON THIS RV S
09/08/2017, UNKNOWN OR OTHER: THE STRAP THAT HOLDS THE ELECTRICAL LINE AND THE PROPANE LINE UNDER THE KITCHEN SIDE OUT BROKE AND THE PROPANE LINE RUBBED ON THE TIRE WHILE TRAVELING ON AN INTERSTATE CAUSING THE LINE TO CUT IN HALF AND PROPANE LEAKED OUT.
09/02/2015, UNKNOWN OR OTHER: THE 5TH WHEEL WAS 2 1/2 MONTHS OLD. AFTER RETURNING FROM A 250 MILE TRIP WE ATTEMPTED TO OPEN THE BEDROOM SLIDE AND IT WOULDN'T OPEN. I PLUGGED IN THE ELECTRICAL PLUG AND OPENED THE SLIDE IN ORDER TO UNLOAD THE REMAINING CLOTHES, THEN I CLOSED THE SLIDE. THIS WAS AT APPROXIMATELY 8:00PM. AT 10:45PM MY GIRLFRIEND HEARD THREE LOUD EXPLOSIONS AND WE RAN OUTSIDE TO FIND THE 5TH WHEEL TOTALLY ENGULFED IN FLAMES. I BEL
08/21/2016, SERVICE BRAKES: TRAILER WHEEL BEARING SEALS LEAKING GREASE, AND COATING BRAKE SHOES WITH GREASE. THREE OUT OF FOUR SEALS WERE LEAKING. REPLACED ALL GREASE SEALS AND REPACKED WHEEL BEARINGS.
08/14/2016, TIRES: 4 GOODYEAR MARATHON WERE INSTALLED ON OUR REFLECTION FIFTH WHEEL CAMPER. THE ORIGINAL TIRES ON THE CAMPER WERE EXCHANGED FOR THE GOODYEAR TIRES. DOT 2VUN1LHR4213 THROUGH 4813. ON JULY 24,2016 THE TIRES WERE ADJUSTED TO 80 PSI. AFTER ABOUT 65 MILES INTO OUR TRIP THE DRIVER SIDE FRONT TIRE EXPLODED AND SHEARED THE TREAD FROM THE TIRE. THE EXPLODING TIRE CAUSED $3700 WORTH OF DAMAGE AS QUOTED BY AN AUTHORIZED DEALER. T
Looking at a 2015 Grand Design Reflection?
The Buyer's Check walks you through it on your phone: what to ask, the outside walk-around, water damage, every system on every power source, with the recalls above built in. You get a report that says what's a walk-away and what to negotiate on.
Checked against NHTSA 2026-10-23. Recall repairs are free at an authorized dealer. Complaints are owner reports to NHTSA and are not verified.