2009 Gulf Stream Tourmaster problems: recalls, complaints and what to check
NHTSA has 3 recalls and 1 owner complaint on file for the 2009 Gulf Stream Tourmaster. Here is what they are, what a technician checks for each kind of fault, and how to look one over before you buy it.
Axles, brakes, suspension and hitch: 2 recalls
Recall 08V420000 (15/08/2008): SUSPENSION
GULF STREAM IS RECALLING 50 MY 2008-2009 CRESCENDO, YELLOWSTONE, AND TOURMASTER RECREATIONAL VEHICLES EQUIPPED WITH SAF-HOLLAND ADL SERIES REAR SUSPENSIONS. IN SOME INSTANCES THE TRANSVERSE BEAM WAS NOT PROPERLY WELDED WHICH COULD RESULT IN A FAILURE OF THE WELD.
Fix: GULF STREAM IS WORKING WITH DAIMLER TRUCKS AND SAF-HOLLAND TO HAVE A VISUAL INSPECTION OF THE ADL TRANSVERSE BEAM PERFORMED. IF A WELD DEFECT IS IDENTIFIED, SAF-HOLLAND WILL PROVIDE A SERVICE REPLACEMENT KIT THAT CONTAINS A NEW TRANSVERSE BEAM, ALL NECESSARY INSTALLATION HARDWARE, BEAM REPLACEMENT, AND INSTRUCTIONS FREE OF CHARGE (PLEASE SEE 08E031). OWNERS MAY CONTACT SAF-HOLLAND AT 1-231-773-3271, DAIMLER TRUCKS AT 1-800-547-0712, OR GULF STREAM AT 1-574-773-7761.
Recall 08V416000 (15/08/2008): SERVICE BRAKES, AIR:SUPPLY:CHECK VALVE
GULF STREAM IS RECALLING 5 MY 2008-2008 TOURMASTER RECREATIONAL VEHICLES EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRING BRAKE MODULATING VALVE CAN BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE. ALSO, DUE TO A MANUFACTURING DEFECT IN THE INTERNAL RUBBER CHECK VALVE INSIDE THE SR-7 SPRING BRAKE MODULATING VALVES, THE VALVES CAN BECOME DEFORMED AND NOT SEAT PROPERLY.
Fix: GULF STREAM IS WORKING WITH DAIMLER TRUCKS TO HAVE THESE VEHICLES REPAIRED (PLEASE SEE 07V302). OWNERS CAN CONTACT DAIMLER TRUCKS AT 1-800-547-071 OR GULF STREAM AT 1-574-773-7761.
What a tech checks: Bearings, brake magnets, worn shackle bolts and bent axles. A trailer that wears tires on the inside edge or pulls to one side usually has an axle or suspension problem. Before you buy: Bolts tight, springs not flat, brakes apply with the breakaway pin pulled.
Chassis and towing lessons · Trailer guide
Motorhome chassis: 1 recall
Recall 08V418000 (15/08/2008): STEERING:GEAR BOX (OTHER THAN RACK AND PINION)
GULF STREAM IS RECALLING 38 MY 2005, 2008 AND 2009 FRIENDSHIP, SCENIC CRUISER, AND TOURMASTER RECREATIONAL VEHICLES EQUIPPED WITH ZF MODEL 8018 STEERING GEARS. THESE STEERING GEARS MAY HAVE BEEN ASSEMBLED WITH THE INCORRECT RECIRCULATING BALL SPACER. THIS COULD POTENTIALLY ALLOW THE RECIRCULATING BALLS TO ESCAPE FROM THE RECIRCULATING BALL CIRCUIT RESULTING IN A LOSS OF STEERING.
Fix: GULF STREAM IS WORKING WITH DAIMLER TRUCKS TO HAVE THE STEERING GEAR REPLACE (PLEASE SEE 07V343). OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712 OR GULF STREAM AT 1-574-773-7761.
What a tech checks: The chassis (Ford, Freightliner, Mercedes, Ram) is serviced by the chassis maker's dealer, not the RV shop. RV techs handle the house, not the drivetrain. Before you buy: Chassis recalls are fixed free at the chassis maker's dealer.
12 volt and 120 volt electrical: 1 complaint
What a tech checks: Voltage drop, grounds, the converter and the transfer switch. Melted shore-cord plugs and bad grounds cause most of the electrical complaints techs actually see. Before you buy: Battery at rest, converter output on shore power, GFCI test, every outlet.
12 V electrical lessons · 120 V and generator lessons · Wiring diagrams
Other: 1 complaint
What owners reported to NHTSA
02/21/2012, ELECTRICAL SYSTEM,EQUIPMENT: 2009 GULF STREAM MOTOR HOME. SOLICITORS WRITE ON BEHALF OF CONSUMER THAT STATES THE MICROWAVE/CONVENTION IN RV HAS BEEN WIRED TO AN INSUFFICIENT BREAKER *TGW THE OWNER'S MANUAL INDICATED THAT A MICROWAVE OVEN REQUIRED 15 AMPS BY ITSELF. HOWEVER, THE MICROWAVE/CONVECTION OVER WAS WIRED ON A CIRCUIT WITH SEVERAL OTHER FIXTURES, INCLUDING LIGHTS, TELEVISION AND A BATHROOM OUTLET. THEY WERE WIRED TO A BREAKER DESIGNED T
Looking at a 2009 Gulf Stream Tourmaster?
The Buyer's Check walks you through it on your phone: what to ask, the outside walk-around, water damage, every system on every power source, with the recalls above built in. You get a report that says what's a walk-away and what to negotiate on.
Checked against NHTSA 2026-10-23. Recall repairs are free at an authorized dealer. Complaints are owner reports to NHTSA and are not verified.