2015 Heartland Bighorn problems: recalls, complaints and what to check
NHTSA has 1 recall and 2 owner complaints on file for the 2015 Heartland Bighorn. Here is what they are, what a technician checks for each kind of fault, and how to look one over before you buy it.
Other: 1 recall
Recall 15V198000 (03/04/2015): EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
Heartland Recreational Vehicles, LLC (Heartland) is recalling certain model year 2015 Bighorn, Cyclone, Edge, Elkridge, Landmark 365, Road Warrior, and Torque fifth wheel and travel trailers. In the affected vehicles, a rivet for the quad entry steps may shear and fail, causing the steps to give when being used.
Fix: Heartland has notified owners, and dealers will replace the defective rivets with bolts, free of charge. The recall began on April 13, 2015. Owners may contact Heartland customer service at 1-877-262-8032. Heartland's number for this recall is 99-01-20.
Axles, brakes, suspension and hitch: 1 complaint
What a tech checks: Bearings, brake magnets, worn shackle bolts and bent axles. A trailer that wears tires on the inside edge or pulls to one side usually has an axle or suspension problem. Before you buy: Bolts tight, springs not flat, brakes apply with the breakaway pin pulled.
Chassis and towing lessons · Trailer guide
Structure, roof and leaks: 1 complaint
What a tech checks: Roof sealant, seams, window and slide seals, and the frame. Water intrusion shows up as delamination, soft floors and stained ceilings months after the leak started. Before you buy: Press the sidewalls and walk the floor; look at every seam and seal.
Roof, leaks and body lessons · Seals and leaks guide
What owners reported to NHTSA
12/28/2015, STRUCTURE: TL* THE CONTACT OWNS A 2015 HEARTLAND BIGHORN. WHILE PARKED, THE FRONT PASSENGER SIDE SLIDE OUT FAILED TO RETRACT BACK INTO THE VEHICLE. AFTER SEVERAL ATTEMPTS, THE SLIDE OUT WAS MANUALLY RETRACTED. WHILE DRIVING APPROXIMATELY 45 MPH, THE PASSENGER NOTICED THAT THE FRONT PASSENGER SIDE SLIDE OUT PROTRUDED APPROXIMATELY SIX INCHES OUTWARD. AFTER SEVERAL ATTEMPTS, THE SLIDE OUT RETRACTED AND SECURED. THE VEHICLE WAS TA
08/21/2016, SUSPENSION: REAR AXLE BRACKETS BROKE OFF OF FRAME CASING REAR AXLE TO MOVE AND BLOW TIRE ON THE FREEWAY. LUCKILY THERE WASN'T AN ACCIDENT . I HAVE CONTACTED DEXTER AXLES AND LIPPERT AND ALSO HEARTLAND AND THEY ALL SAY IT'S NOT THERE PROBLEM
Looking at a 2015 Heartland Bighorn?
The Buyer's Check walks you through it on your phone: what to ask, the outside walk-around, water damage, every system on every power source, with the recalls above built in. You get a report that says what's a walk-away and what to negotiate on.
Checked against NHTSA 2026-10-23. Recall repairs are free at an authorized dealer. Complaints are owner reports to NHTSA and are not verified.