2021 Keystone Alpine problems: recalls, complaints and what to check
NHTSA has 1 recall and 6 owner complaints on file for the 2021 Keystone Alpine. Here is what they are, what a technician checks for each kind of fault, and how to look one over before you buy it.
Leveling and jacks: 1 recall
Recall 22V726000 (29/09/2022): EQUIPMENT:MECHANICAL:INTEGRATED JACK/LEVELER/STABILIZER
Keystone RV Company (Keystone) is recalling certain 2021-2023 Alpine, Avalanche, 2020-2023 Fuzion and Impact travel trailers. The hydraulic leveling leg foot pads may become loose and separate from the vehicle.
Fix: Dealers will inspect the mounting bolt and reinstall with thread locking adhesive, as necessary, free of charge. Owner notification letters were mailed November 10, 2022. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 22-437.
What a tech checks: Hydraulic leaks at the rams and fittings, low fluid, and the panel's fault codes. Electric jacks fail on voltage at the motor and stripped gears. Before you buy: Full cycle on firm ground; look for fluid on the rams.
Hydraulic leveling 3D lab · Slides and leveling lessons
Structure, roof and leaks: 4 complaints
What a tech checks: Roof sealant, seams, window and slide seals, and the frame. Water intrusion shows up as delamination, soft floors and stained ceilings months after the leak started. Before you buy: Press the sidewalls and walk the floor; look at every seam and seal.
Roof, leaks and body lessons · Seals and leaks guide
Other: 3 complaints
Tires: 1 complaint
What a tech checks: Age, load range and pressure. RV tires age out before they wear out, and an underrated tire on a heavy trailer is a blowout waiting to happen. Before you buy: Read the DOT date and the load range on the sidewall.
Chassis, towing and tires lessons · Trailer guide
Axles, brakes, suspension and hitch: 1 complaint
What a tech checks: Bearings, brake magnets, worn shackle bolts and bent axles. A trailer that wears tires on the inside edge or pulls to one side usually has an axle or suspension problem. Before you buy: Bolts tight, springs not flat, brakes apply with the breakaway pin pulled.
Chassis and towing lessons · Trailer guide
What owners reported to NHTSA
11/16/2024, STRUCTURE,UNKNOWN OR OTHER: On or about August 2021, the front frame flexed, causing the body to crack from both front slides lower forward corners going forward. Camper was taken to RVOutlet in Longs SC (now Blue Compass RV)to be repaired in September of 2021. The front frame section was found to be cracked, and was repaired per Keystone TSB procedures, repairs completed in February 2022. These repairs are documented by Keystone, however, I d
10/03/2023, EQUIPMENT: The contact owns a 2021 Keystone Keystone RV. The contact received notification of NHTSA Campaign Number: 22V726000 (Equipment) however, the part to do the recall repair was not yet available. The dealer was contacted and confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue.
09/12/2023, STRUCTURE,TIRES,UNKNOWN OR OTHER: My husband and I purchased a 2021 alpine Keystone 3712 KB fifth wheel on June 2, 2021 around the end of Aug 2021. We left to Oregon for our vacation. Around the first part of September 2021 our trailer started showing signs of issues. We put it in the camper world in Eugene OR and found out that it had front structural damage where they tore out all the the foam off the front goose neck & replaced it with tongue in g
07/18/2024, STRUCTURE: The pin box is moving separately from the framework. What this means is the structure the holds the pin box is starting to fail which could cause the camper to separate from the truck when being pulled down the highway which could cause injury or death to people on that highway. It's a known defect
05/11/2022, SERVICE BRAKES: All four brakes wore out pads and damaged the drums in under 1360 miles. The trailer frame shop where I had new brakes installed (Smiley's Pro Services, 920 W Pearl Jensen Way, LA Conner WA 98287-4720. Ph # 360-466-3629. Invoice #74287) said they had seen this happen to two other trailers in the previous month. The replaement brakes were installed in November 2021. The brakes that failed are DEXTER "NEV-R-ADJUST
02/09/2025, STRUCTURE: Bent/broken frame. We are stranded in Northern CA. The unit is available for inspection. This RV is not safe to be on the road. The insurance company told is that it is non-drivable. See our story below: We have a 3 year old Keystone Alpine 5th Wheel. The frame is bent and cross members are broken. We do not know how it happened. There has been no accident, collision, we didn't run over anything that we recall, no
Looking at a 2021 Keystone Alpine?
The Buyer's Check walks you through it on your phone: what to ask, the outside walk-around, water damage, every system on every power source, with the recalls above built in. You get a report that says what's a walk-away and what to negotiate on.
Checked against NHTSA 2026-10-23. Recall repairs are free at an authorized dealer. Complaints are owner reports to NHTSA and are not verified.