2022 Keystone Montana problems: recalls, complaints and what to check
NHTSA has 3 recalls and 7 owner complaints on file for the 2022 Keystone Montana, including 3 fires. Here is what they are, what a technician checks for each kind of fault, and how to look one over before you buy it.
Other: 1 recall, 7 complaints
Recall 22V604000 (09/08/2022): EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
Keystone RV Company (Keystone) is recalling certain 2022 Dutchmen Aspen Trail, Coleman, Colorado, Voltage, Yukon, Keystone Carbon, Cougar, Hideout, Montana, Outback, Passport, Raptor, Retreat, Springdale, Sprinter and 2022-2023 Keystone Bullet travel trailers. The electric retractable awning has a welded seam on the fabric that may separate, potentially allowing the awning to drop beyond normal operation.
Fix: Dealers will repair or replace the awning fabric, free of charge. Owner notification letters were mailed September 16, 2022. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 22-434.
12 volt and 120 volt electrical: 1 recall, 2 complaints
Recall 22V144000 (11/03/2022): ELECTRICAL SYSTEM
Keystone RV Company (Keystone) is recalling certain 2022 Keystone Arcadia, Carbon, Alpine, Avalanche, Cougar, Fuzion, High Country Montana, Hideout, Impact, Montana, Outback, Passport, Raptor, Springdale, and 2021-2022 Sprinter and Bullet fifth wheel and travel trailers. The solar controller may be incorrectly wired, causing certain components and safety alarms, such as carbon monoxide and propane gas detectors, to become inoperable.
Fix: Dealers will inspect voltage readings and correct the wiring as necessary, free of charge. Owner notification letters were mailed May 2, 2022. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 22-423.
What a tech checks: Voltage drop, grounds, the converter and the transfer switch. Melted shore-cord plugs and bad grounds cause most of the electrical complaints techs actually see. Before you buy: Battery at rest, converter output on shore power, GFCI test, every outlet.
12 V electrical lessons · 120 V and generator lessons · Wiring diagrams
LP gas and gas appliances: 1 recall
Recall 24V234000 (27/03/2024): EQUIPMENT:APPLIANCE:OVEN/STOVE/COOKTOP
Keystone RV Company (Keystone) is recalling certain 2021-2023 Montana, 2021-2022 Montana High Country, 2022-2024 Fuzion, 2021 Crossroads Cruiser, and 2024 Dutchmen Aspen Trail LOFT vehicles. The LED backlight circuit board in the cooktop range may fail, causing the board to overheat.
Fix: Dealers can remove the LED backlights or terminate the circuit for the red LED lights, free of charge. Owner notification letters were mailed May 2, 2024. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 24-452.
What a tech checks: Regulator, lines and fittings, then the appliances: furnace, water heater, range. A proper pressure-drop leak test is the first thing a tech does on an LP complaint. Before you buy: Smell for gas with the tank open; have a shop do the leak test.
LP and furnace lessons · Furnace guide · Furnace 3D lab · Water heater 3D lab
Structure, roof and leaks: 1 complaint
What a tech checks: Roof sealant, seams, window and slide seals, and the frame. Water intrusion shows up as delamination, soft floors and stained ceilings months after the leak started. Before you buy: Press the sidewalls and walk the floor; look at every seam and seal.
Roof, leaks and body lessons · Seals and leaks guide
Axles, brakes, suspension and hitch: 1 complaint
What a tech checks: Bearings, brake magnets, worn shackle bolts and bent axles. A trailer that wears tires on the inside edge or pulls to one side usually has an axle or suspension problem. Before you buy: Bolts tight, springs not flat, brakes apply with the breakaway pin pulled.
Chassis and towing lessons · Trailer guide
What owners reported to NHTSA
12/09/2025, ELECTRICAL SYSTEM,EQUIPMENT: The contact owns a 2022 Keystone Montana RV. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 22V144000(Electrical System, Equipment) several times. Additionally, the contact stated that the vehicle had experienced electrical failures and was taken to the dealer, where it was discovered that the inverter had caught on fire due to the solar controller failure. The contact was in
09/01/2022, WHEELS: Stopped by another driver that had been following me. Driver stated that we had lost a wheel / tire off of our 5th wheel travel trailer and that he had stopped and picked it up for us. Upon investigating what had happened, found 6 of the 8 lug studs to be snapped off flush or below the outer surface of the drum brake hub assembly. Lug nuts are checked with a torque wrench to 120 ft lbs prior to each trip. Lug nuts ha
08/21/2023, UNKNOWN OR OTHER,EQUIPMENT: LED lights behind the burner knobs on the stove caught fire. When you turn on a burner there is a LED light behind the knob that lights up red to identify it is on. Turned it on to start cooking and while preparing food on the island after a few minutes smelled plastic burning. Turned around and a flame was coming out behind the burner knob. Quickly was able to extinguish it. Luckily I was standing right there.
06/02/2026, ELECTRICAL SYSTEM: this is about a recreational vehicle safety recall 24V-234 safety advisory 24-452 Suburban stove LED backlight printed circuit boards that were defective and should have been fixed or replaced under warranty. What good is a warranty if they just want to cut and terminate the circuit? Would it be ok to cut and terminate wires to a defective air bag in a vehicle? I would like to know why. We bought this product and t
05/23/2022, EQUIPMENT: While traveling with the trailer the slide topper blew off the the holders. It did not come of the trailer complete but if it would have the roller could have become a projectile and damage a vehicle coming from behind. I believe it should have had two screws in the front and rear holder so if a screw bloke the other one would protect the roller. The one I had only had one screw installed but there is a second hole
04/28/2025, EQUIPMENT,UNKNOWN OR OTHER: On 4/26/2025 The Suburban stove caught on fire. This is a serious issue, if were not in the RV to catch this, all our belongings and our RV would have went up in flames. Now the company wants to do a half baked repair.
Looking at a 2022 Keystone Montana?
The Buyer's Check walks you through it on your phone: what to ask, the outside walk-around, water damage, every system on every power source, with the recalls above built in. You get a report that says what's a walk-away and what to negotiate on.
Checked against NHTSA 2026-10-23. Recall repairs are free at an authorized dealer. Complaints are owner reports to NHTSA and are not verified.