2019 Thor Motor Coach Aria problems: recalls, complaints and what to check
NHTSA has 4 recalls and 2 owner complaints on file for the 2019 Thor Motor Coach Aria. Here is what they are, what a technician checks for each kind of fault, and how to look one over before you buy it.
Axles, brakes, suspension and hitch: 2 recalls
Recall 20V167000 (20/03/2020): SERVICE BRAKES, AIR:DISC:CALIPER
Thor Motor Coach (TMC) is recalling certain 2019-2020 Aria 3401, 3601, 3901, 3902, and Venetian G36, J40, L40, M37, R40, and S40 motorhomes built on DTNA chassis. The brake caliper mounting bolts may have been insufficiently tightened.
Fix: DTNA will notify owners, and DTNA dealers will inspect and repair the vehicles, free of charge. The recall began on May 20, 2020. Owners may contact DTNA customer service at 1-800-547-0712 or TMC customer service at 1-877-855-2867.
Recall 20V418000 (20/07/2020): EXTERIOR LIGHTING:BRAKE LIGHTS
Thor Motor Coach (TMC) is recalling certain 2017-2020 Aria, Venetian and Tuscany, 2017 Tuscany XTE and 2017-2019 Palazzo motorhomes vehicles that received an inspection-only remedy for recall 18V-763. The rear mounted Power Distribution Module (PDM) may have been damaged during manufacturing, possibly resulting in the rear marker lights, brake lights, or turn signals not functioning.
Fix: TMC will notify owners, and Daimler Trucks dealers will replace the PDM, free of charge. Owner letters were mailed October 6, 2021. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000196.
What a tech checks: Bearings, brake magnets, worn shackle bolts and bent axles. A trailer that wears tires on the inside edge or pulls to one side usually has an axle or suspension problem. Before you buy: Bolts tight, springs not flat, brakes apply with the breakaway pin pulled.
Chassis and towing lessons · Trailer guide
Structure, roof and leaks: 1 recall, 1 complaint
Recall 21V522000 (08/07/2021): STRUCTURE
Thor Motor Coach (TMC) is recalling certain 2019 Challenger, Palazzo, Tuscany, 2019-2020 Miramar, 2019-2021 Aria, Outlaw, and Venetian recreational vehicles equipped with Hehr 6400 series windows. The adhesive that bonds the vented portion of the window may fail.
Fix: Dealers will inspect the windows, and replace the vent if necessary, free of charge. Owner notification letters were mailed September 8, 2021. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000232.
What a tech checks: Roof sealant, seams, window and slide seals, and the frame. Water intrusion shows up as delamination, soft floors and stained ceilings months after the leak started. Before you buy: Press the sidewalls and walk the floor; look at every seam and seal.
Roof, leaks and body lessons · Seals and leaks guide
Tires: 1 recall
Recall 20V559000 (15/09/2020): TIRES:VALVE
Thor Motor Coach (TMC) is recalling certain 2018-2021 Aria, Palazzo, Tuscany, and Venetian motorhomes built on a Daimler Trucks (DTNA) chassis. The tire valve stem extension for the inner wheel may contact the outer wheel rim opening and become damaged.
Fix: TMC will notify owners, and DTNA dealers will inspect the inner wheel valve stem stabilizers, and adjust as needed and/or replace the inner valve stem, free of charge. The recall began November 2, 2020. Owners may contact TMC customer service at 1-800-524-5210 extension 104 or DTNA customer service at 1-800-547-0712. TMC's number for this recall is RC000204. DTNA's number for this recall is FL-861.
What a tech checks: Age, load range and pressure. RV tires age out before they wear out, and an underrated tire on a heavy trailer is a blowout waiting to happen. Before you buy: Read the DOT date and the load range on the sidewall.
Chassis, towing and tires lessons · Trailer guide
Other: 2 complaints
Doors, windows, steps and lights: 1 complaint
What a tech checks: Mostly adjustments and wear: steps that stop halfway on a bad switch, doors out of alignment after a slide shifted, exterior lights with a corroded ground. Before you buy: Every door, lock, window and light.
12 volt and 120 volt electrical: 1 complaint
What a tech checks: Voltage drop, grounds, the converter and the transfer switch. Melted shore-cord plugs and bad grounds cause most of the electrical complaints techs actually see. Before you buy: Battery at rest, converter output on shore power, GFCI test, every outlet.
12 V electrical lessons · 120 V and generator lessons · Wiring diagrams
What owners reported to NHTSA
09/24/2026, VISIBILITY,UNKNOWN OR OTHER: I have had 2 side windows fly off my motorhome while on the road .. did not see them fly.off but we're gone when I got to my destination ... There is another one ready to fly off ... The adhesive holding the bottom of the window has failed ... Have secured the remaining windows with rope and tape to keep them from flying off ... This is a serious safety issue with this motorhome and she is only 7 years old
04/08/2021, ELECTRICAL SYSTEM,STRUCTURE,UNKNOWN OR OTHER: WHEN WE RESTARTED THE ENGINE OF OUR MOTOR COACH AFTER FUELING, THE AWNING AUTOMATICALLY EXTENDED. IT IT NOT SUPPOSED TO BE POSSIBLE TO EXTEND THE AWNING WHILE THE ENGINE IS ON. WE WERE ALSO TOLD THERE IS A SAFETY FEATURE THAT WILL NOT ALLOW THE VEHICLE TO DRIVE WITH THE AWNING EXTENDED. WHEN WE PULLED OUT OF THE FUELING LANE, THE AWNING CAUGHT THE PUMP AND DAMAGED IT.
Looking at a 2019 Thor Motor Coach Aria?
The Buyer's Check walks you through it on your phone: what to ask, the outside walk-around, water damage, every system on every power source, with the recalls above built in. You get a report that says what's a walk-away and what to negotiate on.
Checked against NHTSA 2026-10-23. Recall repairs are free at an authorized dealer. Complaints are owner reports to NHTSA and are not verified.