2019 Thor Motor Coach Challenger problems: recalls, complaints and what to check
NHTSA has 3 recalls and 1 owner complaint on file for the 2019 Thor Motor Coach Challenger, including 1 fire. Here is what they are, what a technician checks for each kind of fault, and how to look one over before you buy it.
Structure, roof and leaks: 1 recall
Recall 21V522000 (08/07/2021): STRUCTURE
Thor Motor Coach (TMC) is recalling certain 2019 Challenger, Palazzo, Tuscany, 2019-2020 Miramar, 2019-2021 Aria, Outlaw, and Venetian recreational vehicles equipped with Hehr 6400 series windows. The adhesive that bonds the vented portion of the window may fail.
Fix: Dealers will inspect the windows, and replace the vent if necessary, free of charge. Owner notification letters were mailed September 8, 2021. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000232.
What a tech checks: Roof sealant, seams, window and slide seals, and the frame. Water intrusion shows up as delamination, soft floors and stained ceilings months after the leak started. Before you buy: Press the sidewalls and walk the floor; look at every seam and seal.
Roof, leaks and body lessons · Seals and leaks guide
Doors, windows, steps and lights: 1 recall
Recall 18V812000 (16/11/2018): VISIBILITY
Thor Motor Coach (TMC) is recalling certain 2017-2019 Thor Challenger, Miramar, and Outlaw motorhomes. The motorized windshield roller shade at the driver's seating position may unroll without warning while driving.
Fix: TMC will notify owners, and dealers will install a fastener to ensure the motor will not allow the shade to roll down during while driving. The recall began January 10, 2019. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000165.
What a tech checks: Mostly adjustments and wear: steps that stop halfway on a bad switch, doors out of alignment after a slide shifted, exterior lights with a corroded ground. Before you buy: Every door, lock, window and light.
Other: 1 recall
Recall 19V504000 (30/06/2019): EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
Thor Motor Coach (TMC) is recalling certain 2019-2020 Challenger, Miramar, Magnitude, Outlaw, Omni, and Palazzo motorhomes. The vehicle control system software may cause the slide-out room to move unexpectedly.
Fix: TMC will notify owners, and dealers will update the affected software, free of charge. The recall is expected to begin August 28, 2019. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000170.
12 volt and 120 volt electrical: 1 complaint
What a tech checks: Voltage drop, grounds, the converter and the transfer switch. Melted shore-cord plugs and bad grounds cause most of the electrical complaints techs actually see. Before you buy: Battery at rest, converter output on shore power, GFCI test, every outlet.
12 V electrical lessons · 120 V and generator lessons · Wiring diagrams
What owners reported to NHTSA
08/20/2021, ELECTRICAL SYSTEM: The contact owns a Thor Motor Coach Challenger. The contact stated while the RV was parked and covered in the driveway, the contact entered the RV and became aware that the inside of the RV was severely burned. The contact stated that the fire was contained inside of the RV. There was no visible fire damage on the outside of the RV. The contact stated that the fuse panel was completely burned. The insurance company h
Looking at a 2019 Thor Motor Coach Challenger?
The Buyer's Check walks you through it on your phone: what to ask, the outside walk-around, water damage, every system on every power source, with the recalls above built in. You get a report that says what's a walk-away and what to negotiate on.
Checked against NHTSA 2026-10-23. Recall repairs are free at an authorized dealer. Complaints are owner reports to NHTSA and are not verified.