2020 Thor Motor Coach Four Winds problems: recalls, complaints and what to check
NHTSA has 9 recalls and 1 owner complaint on file for the 2020 Thor Motor Coach Four Winds. Here is what they are, what a technician checks for each kind of fault, and how to look one over before you buy it.
Motorhome chassis: 4 recalls
Recall 20V444000 (29/07/2020): AIR BAGS
Thor Motor Coach (Thor) is recalling certain 2020-2021 Daybreak, Four Winds, Quantum, Delano, Tiburon, Chateau and Freedom Elite motorhomes and 2020 Gemini, Chateau Citation, Compass, Siesta, and Synergy motorhomes built on Sprinter Van chassis (platform 970 (VS30), equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.
Fix: Thor will notify owners, and Mercedes-Benz dealers will inspect the wire harness routing for both front seats and will repair the wiring and add clips or cable ties as needed, free of charge. This recall began August 13, 2020. Owners may contact Thor customer service at 1-877-855-2867 Mercedes-Benz customer service at 1-877-762-8267. Thor's number for this recall is RC000200.
Recall 20V178000 (25/03/2020): POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT
Thor Motor Coach (TMC) is recalling certain 2020 Chateau 31W and 31WV, Quantum KW29 and LF31, Vegas 24.1 and Axis 24.1 motorhomes and 2020-2021 Four Winds 24F, 28Z, and 31E motorhomes built on a Ford chassis. The rear axle differential may have an insufficient amount of fluid, possibly resulting in a failure of the rear axle assembly and a driveshaft separation.
Fix: Ford will notify owners, and Ford or Lincoln dealers will inspect the rear axle differential fluid level and adjust it, or replace the rear axle as necessary, free of charge. The recall is began May 22, 2020. Owners may contact Ford customer service at 1-866-436-7332 or TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000188.
Recall 20V303000 (27/05/2020): ELECTRONIC STABILITY CONTROL (ESC)
Thor Motor Coach (TMC) is recalling certain 2020-2021 Quantum, Chateau and Four Winds, and 2020 Vegas and Axis motorhomes built on a Ford E-series chassis. A wire harness in the rear of the vehicle may contact the vehicle frame, resulting in damage to the circuits that support the fuel pump and the anti-lock braking system (ABS).
Fix: TMC will notify owners, and Ford dealers will inspect the wire harness for damage. If no damage is found, dealers will apply anti-abrasion tape over the area and ensure clearance to surrounding components. If damage is found, dealers will splice in new wire and apply anti-abrasion tape over the area and ensure clearance to surrounding components. All services will be performed free of charge. The recall The recall began June 25, 2020., 2020. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000189.
Recall 20V308000 (27/05/2020): POWER TRAIN:AUTOMATIC TRANSMISSION
Thor Motor Coach (TMC) is recalling certain 2020 Daybreak, Four Winds, Delano, Gemini, Quantum, Tiburon, Chateau Citation, Compass, Chateau, Siesta, Freedom Elite, and Synergy motorhomes built on Mercedes-Benz Sprinter chassis [platform 907 (VS30)] equipped with automatic transmissions. The owner's manual does not correctly specify the certain conditions under which the automatic parking function (Auto-P) operates.
Fix: TMC will notify owners, and a Mercedes Benz dealer will supplement the Operator's Manual with a correct description of the Auto-P function equipped in the vehicle. This recall began June 25, 2020. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000190.
What a tech checks: The chassis (Ford, Freightliner, Mercedes, Ram) is serviced by the chassis maker's dealer, not the RV shop. RV techs handle the house, not the drivetrain. Before you buy: Chassis recalls are fixed free at the chassis maker's dealer.
12 volt and 120 volt electrical: 3 recalls
Recall 20V711000 (17/11/2020): ELECTRICAL SYSTEM
Thor Motor Coach (TMC) is recalling certain 2020-2021 Daybreak, Four Winds, Chateau, Freedom Elite, Quantum motorhomes built on a Chevrolet chassis. The BIM (Battery Isolation Manager)/BIR (Battery Isolation Relay) is not watertight when exposed to engine compartment heat.
Fix: TMC will notify owners, and dealers will replace the BIM/BIR with a Trombetta solenoid, free of charge. The recall began January 13, 2021. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000206.
Recall 19V775000 (28/10/2019): ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
Thor Motor Coach (TMC) is recalling certain 2019-2020 Chateau 22B, 22E, 23U, 24F, 25V, and 28A, Daybreak 22GO, Four Winds 22B, 22E, 24F, 26B and 28A, Freedom Elite 22HE and 2020 Quantum GR22, and SE22 motorhomes. The seatbelt-unfastened warning light will not illuminate for approximately five seconds after the ignition is moved to the "on" or "start" position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Fix: GM will notify TMC owners, and dealers will reprogram the instrument panel cluster, free of charge. The recall began October 3, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438, GMC customer service at 1-800-462-8782 or TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000177.
Recall 19V609000 (20/08/2019): ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES
Thor Motor Coach (TMC) is recalling certain 2020 Chateau, Daybreak, Four Winds, Freedom Elite, Majestic, Outlaw and Quantum motorhomes. The battery cables may loosen on the battery isolation manager (BIM) or battery isolation relay (BIR), causing premature BIN/BIR failure or electrical arcing.
Fix: TMC will notify owners, and dealers will install lock washers to properly secure the battery cable to the BIM/BIR. If the cable was loose, dealers will also replace the BIM/BIR, free of charge. The recall began October 10, 2019. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000172.
What a tech checks: Voltage drop, grounds, the converter and the transfer switch. Melted shore-cord plugs and bad grounds cause most of the electrical complaints techs actually see. Before you buy: Battery at rest, converter output on shore power, GFCI test, every outlet.
12 V electrical lessons · 120 V and generator lessons · Wiring diagrams
Structure, roof and leaks: 1 recall, 1 complaint
Recall 20V312000 (28/05/2020): STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
Thor Motor Coach (TMC) is recalling certain 2020 Daybreak, Four Winds, Delano, Gemini, Quantum, Tiburon, Chateau Citation, Compass, Chateau, Siesta, Freedom Elite, and Synergy motorhomes built on Mercedes Benz Sprinter chassis [platform 907 (VS30)]. The rear part of the fender liner on the front axle may contact and chafe the brake hose, possibly resulting in a loss of brake fluid.
Fix: TMC will notify owners, and an authorized Mercedes-Benz dealer will inspect the brake hoses for chafing and replacement if necessary. The fender liner will also be altered to permit more clearance. All repairs will be performed free of charge. This recall began June 25, 2020. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000191.
What a tech checks: Roof sealant, seams, window and slide seals, and the frame. Water intrusion shows up as delamination, soft floors and stained ceilings months after the leak started. Before you buy: Press the sidewalls and walk the floor; look at every seam and seal.
Roof, leaks and body lessons · Seals and leaks guide
Doors, windows, steps and lights: 1 recall
Recall 20V458000 (05/08/2020): SEAT BELTS
Thor Motor Coach (TMC) is recalling certain 2020-2021 Daybreak 23DB, 2018-2021 Four Winds 23U, and 2018-2021 Chateau 23U motorhomes. Bolts of the wrong size were used to secure the barrel chair pedestals, allowing the pedestal to separate from the floor in the event of a crash. As such, these motorhomes fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 207, "Seating Systems" and number 210, "Seat Belt Assembly Anchorages."
Fix: TMC will notify owners, and dealers will inspect the pedestal bolt size, correcting the hardware as necessary, free of charge. This recall began September 14, 2020. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000202.
What a tech checks: Mostly adjustments and wear: steps that stop halfway on a bad switch, doors out of alignment after a slide shifted, exterior lights with a corroded ground. Before you buy: Every door, lock, window and light.
Other: 1 complaint
What owners reported to NHTSA
02/01/2021, STRUCTURE,EQUIPMENT: TL* THE CONTACT OWNS A 2020 THOR MOTOR COACH FOUR WINDS. THE CONTACT STATED THAT WHILE DRIVING ON A WINDY DAY AT VARIOUS SPEEDS, THE DRIVER'S SIDE SLIDE-OUT EXTENDED WITHOUT WARNING. THE CONTACT PULLED OVER TO RE-INSERT THE SLIDE-OUT. THE VEHICLE WAS TAKEN TO LA MESA RV CENTER MESA (1740 S MESA DR, MESA, AZ 85210, (833) 892-6542) WHERE THE TECHNICIAN WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS NOT NOTIF
Looking at a 2020 Thor Motor Coach Four Winds?
The Buyer's Check walks you through it on your phone: what to ask, the outside walk-around, water damage, every system on every power source, with the recalls above built in. You get a report that says what's a walk-away and what to negotiate on.
Checked against NHTSA 2026-10-23. Recall repairs are free at an authorized dealer. Complaints are owner reports to NHTSA and are not verified.