2026 Thor Motor Coach Four Winds problems: recalls, complaints and what to check
NHTSA has 2 recalls and 2 owner complaints on file for the 2026 Thor Motor Coach Four Winds. Here is what they are, what a technician checks for each kind of fault, and how to look one over before you buy it.
Other: 1 recall, 1 complaint
Recall 25V171000 (20/03/2025): EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
Thor Motor Company (TMC) is recalling certain 2023-2026 Axis, Chateau, Four Winds, 2023-2025 Coleman, Echelon, Freedom Elite, Geneva, Outlaw, Quantum, Vegas, 2025 Eddie Bauer, Freedom Traveler, Pasadena, and 2024-2025 Magnitude motorhomes. The slide-Out room can be deployed without the parking brake engaged, allowing the room to extend while the vehicle is in motion.
Fix: Dealers will replace the park brake harness, free of charge. Owner notification letters were mailed April 28, 2025. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000325.
LP gas and gas appliances: 1 recall
Recall 25V709000 (17/10/2025): EQUIPMENT:RECREATIONAL VEHICLE/TRAILER:LPG SYSTEMS:LINES AND FITTINGS
Thor Motor Coach (TMC) is recalling certain 2026 Geneva, 2025-2026 Quantum, Four Winds, Pasadena, Eddie Bauer, Chateau, Freedom Elite, and Coleman recreational vehicles. A P-clamp may not have been installed, allowing the Liquid Propane (LP) generator hose to contact the exhaust.
Fix: Dealers will install a P-clamp to secure the LP hose, free of chare. Owner notification letters were mailed December 15, 2025. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000335.
What a tech checks: Regulator, lines and fittings, then the appliances: furnace, water heater, range. A proper pressure-drop leak test is the first thing a tech does on an LP complaint. Before you buy: Smell for gas with the tank open; have a shop do the leak test.
LP and furnace lessons · Furnace guide · Furnace 3D lab · Water heater 3D lab
Axles, brakes, suspension and hitch: 2 complaints
What a tech checks: Bearings, brake magnets, worn shackle bolts and bent axles. A trailer that wears tires on the inside edge or pulls to one side usually has an axle or suspension problem. Before you buy: Bolts tight, springs not flat, brakes apply with the breakaway pin pulled.
Chassis and towing lessons · Trailer guide
Tires: 1 complaint
What a tech checks: Age, load range and pressure. RV tires age out before they wear out, and an underrated tire on a heavy trailer is a blowout waiting to happen. Before you buy: Read the DOT date and the load range on the sidewall.
Chassis, towing and tires lessons · Trailer guide
What owners reported to NHTSA
07/29/2025, WHEELS: The vehicle I rented — a Thor RV based on a Ford E350 — was handed over with a missing lug nut on one wheel and a dangerously loose lug nut on the opposite rear wheel. The component that failed is part of the wheel fastener system (lugs/nuts/bolts). It is not available for inspection now, as the vehicle has since been returned to the rental company. This situation posed a serious safety risk — had the remaining nuts
04/26/2026, TIRES,WHEELS,EQUIPMENT: 2026 Ford E-350 Chassis / Thor Four Winds 25Z motor coach; which only had about 800 miles on it! While driving north on I-81, the low tire pressure warning came on. So, I switched to the tire pressure screen and the outside left tire was dramatically loosing pressure from recommended 65 psi - dropping to around 30 psi within a few mile. We pulled of onto the shoulder, with only 3-4’ clearance of traffic. My wife and
Looking at a 2026 Thor Motor Coach Four Winds?
The Buyer's Check walks you through it on your phone: what to ask, the outside walk-around, water damage, every system on every power source, with the recalls above built in. You get a report that says what's a walk-away and what to negotiate on.
Checked against NHTSA 2026-10-23. Recall repairs are free at an authorized dealer. Complaints are owner reports to NHTSA and are not verified.