2025 Thor Motor Coach Geneva problems: recalls, complaints and what to check
NHTSA has 1 recall and 2 owner complaints on file for the 2025 Thor Motor Coach Geneva. Here is what they are, what a technician checks for each kind of fault, and how to look one over before you buy it.
Other: 1 recall, 2 complaints
Recall 25V171000 (20/03/2025): EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
Thor Motor Company (TMC) is recalling certain 2023-2026 Axis, Chateau, Four Winds, 2023-2025 Coleman, Echelon, Freedom Elite, Geneva, Outlaw, Quantum, Vegas, 2025 Eddie Bauer, Freedom Traveler, Pasadena, and 2024-2025 Magnitude motorhomes. The slide-Out room can be deployed without the parking brake engaged, allowing the room to extend while the vehicle is in motion.
Fix: Dealers will replace the park brake harness, free of charge. Owner notification letters were mailed April 28, 2025. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000325.
Doors, windows, steps and lights: 1 complaint
What a tech checks: Mostly adjustments and wear: steps that stop halfway on a bad switch, doors out of alignment after a slide shifted, exterior lights with a corroded ground. Before you buy: Every door, lock, window and light.
12 volt and 120 volt electrical: 1 complaint
What a tech checks: Voltage drop, grounds, the converter and the transfer switch. Melted shore-cord plugs and bad grounds cause most of the electrical complaints techs actually see. Before you buy: Battery at rest, converter output on shore power, GFCI test, every outlet.
12 V electrical lessons · 120 V and generator lessons · Wiring diagrams
What owners reported to NHTSA
12/19/2025, EXTERIOR LIGHTING,UNKNOWN OR OTHER: I brought a 2025 THOR RV Geneva VS24, VIN: [XXX] . THOR and Blue Compass RV drove this RV for 2046 miles with the headlights not working, a bad headlight relay was found by Ford, the part is a THOR relay. This is a road safely issue driving roads without headlights. Second issue; I have to disconnect the smoke alarm to use the stove top, THOR didn't install a exhaust fan/vent to get rid of smoke when cooking. Thi
05/12/2025, ELECTRICAL SYSTEM,EQUIPMENT: Fumes inside motorhome when running Motorcoach overhead air conditioner on Generator power with vehicle engine off. I became irritable, felt ill and my eyes were swollen. It required a day to feel normal again. Due to this problem, I did not run both devices together again for the remainder of my 11 day trip. I will take it into the dealer this week for analysis.
Looking at a 2025 Thor Motor Coach Geneva?
The Buyer's Check walks you through it on your phone: what to ask, the outside walk-around, water damage, every system on every power source, with the recalls above built in. You get a report that says what's a walk-away and what to negotiate on.
Checked against NHTSA 2026-10-23. Recall repairs are free at an authorized dealer. Complaints are owner reports to NHTSA and are not verified.