2021 Thor Motor Coach Hurricane problems: recalls, complaints and what to check
NHTSA has 2 recalls and 2 owner complaints on file for the 2021 Thor Motor Coach Hurricane. Here is what they are, what a technician checks for each kind of fault, and how to look one over before you buy it.
Other: 1 recall, 1 complaint
Recall 23V121000 (24/02/2023): EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
Thor Motor Coach (TMC) is recalling certain 2018-2021 Hurricane and Windsport recreational vehicles. The driver and front passenger overhead cabinets may detach.
Fix: Dealers will inspect and reinstall the overhead cabinets, if necessary, free of charge. Owner notification letters were mailed March 15, 2023. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000290.
12 volt and 120 volt electrical: 1 recall
Recall 20V498000 (21/08/2020): ELECTRICAL SYSTEM
Thor Motor Coach (Thor) is recalling certain 2019-2021 Hurricane and Windsport motorhomes, models 27B, 29M, 32T, 33X, 34J, 34R and 35M. The electronic control center circuit board may be damaged from voltages over 17 volts causing damage to the circuit board.
Fix: Thor will notify owners, and dealers will add an additional circuit module to the existing component board to provide reverse polarity and over-current protection, free of charge. The recall began October 20, 2020. Owners may contact Thor customer service at 1-877-855-2867. Thor's number for this recall is RC000203.
What a tech checks: Voltage drop, grounds, the converter and the transfer switch. Melted shore-cord plugs and bad grounds cause most of the electrical complaints techs actually see. Before you buy: Battery at rest, converter output on shore power, GFCI test, every outlet.
12 V electrical lessons · 120 V and generator lessons · Wiring diagrams
Motorhome chassis: 3 complaints
What a tech checks: The chassis (Ford, Freightliner, Mercedes, Ram) is serviced by the chassis maker's dealer, not the RV shop. RV techs handle the house, not the drivetrain. Before you buy: Chassis recalls are fixed free at the chassis maker's dealer.
What owners reported to NHTSA
08/20/2026, ENGINE AND ENGINE COOLING: See attached document for complaint.
08/18/2025, ENGINE AND ENGINE COOLING,UNKNOWN OR OTHER,ENGINE: The floor on my coach above the Catalytic converter has become soft. I am being told it is from the heat from the Catalytic converter. O called Thor and was told there should be a heat shield there campong world of Ashville says there is not a heat shield on it I have a picture no shield is present. I mistakenly told them something was cutoff during a recall I thought it was aa heat shield but it was something aro
Looking at a 2021 Thor Motor Coach Hurricane?
The Buyer's Check walks you through it on your phone: what to ask, the outside walk-around, water damage, every system on every power source, with the recalls above built in. You get a report that says what's a walk-away and what to negotiate on.
Checked against NHTSA 2026-10-23. Recall repairs are free at an authorized dealer. Complaints are owner reports to NHTSA and are not verified.