2024 Thor Motor Coach Quantum problems: recalls, complaints and what to check
NHTSA has 1 recall and 2 owner complaints on file for the 2024 Thor Motor Coach Quantum. Here is what they are, what a technician checks for each kind of fault, and how to look one over before you buy it.
Other: 1 recall, 1 complaint
Recall 25V171000 (20/03/2025): EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
Thor Motor Company (TMC) is recalling certain 2023-2026 Axis, Chateau, Four Winds, 2023-2025 Coleman, Echelon, Freedom Elite, Geneva, Outlaw, Quantum, Vegas, 2025 Eddie Bauer, Freedom Traveler, Pasadena, and 2024-2025 Magnitude motorhomes. The slide-Out room can be deployed without the parking brake engaged, allowing the room to extend while the vehicle is in motion.
Fix: Dealers will replace the park brake harness, free of charge. Owner notification letters were mailed April 28, 2025. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000325.
12 volt and 120 volt electrical: 2 complaints
What a tech checks: Voltage drop, grounds, the converter and the transfer switch. Melted shore-cord plugs and bad grounds cause most of the electrical complaints techs actually see. Before you buy: Battery at rest, converter output on shore power, GFCI test, every outlet.
12 V electrical lessons · 120 V and generator lessons · Wiring diagrams
Motorhome chassis: 2 complaints
What a tech checks: The chassis (Ford, Freightliner, Mercedes, Ram) is serviced by the chassis maker's dealer, not the RV shop. RV techs handle the house, not the drivetrain. Before you buy: Chassis recalls are fixed free at the chassis maker's dealer.
Doors, windows, steps and lights: 1 complaint
What a tech checks: Mostly adjustments and wear: steps that stop halfway on a bad switch, doors out of alignment after a slide shifted, exterior lights with a corroded ground. Before you buy: Every door, lock, window and light.
What owners reported to NHTSA
10/28/2025, POWER TRAIN,ELECTRICAL SYSTEM,ENGINE AND ENGINE COOLING: The contact owns a 2024 Thor Quantum RV. The contact stated that while parked with the engine idling, the RV started to vibrate and shake before shutting off. The contact was unable to restart the RV. The RV was later towed to the local mechanic. The local mechanic diagnosed the RV and determined that the fuel pump control module had failed due to condensation from the A/C drainage pipe leaking onto the module. The
06/11/2025, ELECTRICAL SYSTEM,EXTERIOR LIGHTING,UNKNOWN OR OTHER: Drove from Gibson Louisiana to Abita Springs Ocean Canyon RV park. Upon arrival we had a buzzer alert going off under dash, we then parked to RV. Tried to put jacks down, did not respond, tried 12v lights did not work, tried slides, again no response. We then plugged in and were able to get jacks and slides out, some lights worked. Still alarm under dash, checked 12 coach battery, almost dead. Called a mobile RV te
Looking at a 2024 Thor Motor Coach Quantum?
The Buyer's Check walks you through it on your phone: what to ask, the outside walk-around, water damage, every system on every power source, with the recalls above built in. You get a report that says what's a walk-away and what to negotiate on.
Checked against NHTSA 2026-10-23. Recall repairs are free at an authorized dealer. Complaints are owner reports to NHTSA and are not verified.