2010 Tiffin Allegro Bus problems: recalls, complaints and what to check
NHTSA has 3 recalls and 1 owner complaint on file for the 2010 Tiffin Allegro Bus. Here is what they are, what a technician checks for each kind of fault, and how to look one over before you buy it.
Doors, windows, steps and lights: 1 recall, 1 complaint
Recall 16V532000 (13/07/2016): VISIBILITY:WINDSHIELD WIPER/WASHER
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain model year 2007-2011 Allegro, Allegro Bus, Phaeton, and Zephyr motorhomes, 2007-2010 Allegro Bay motorhomes, and 2010-2011 Allegro Breeze motorhomes. The windshield wiper arms on the affected vehicles may break off.
Fix: Tiffin will notify owners, and dealers will replace the wiper blade arms, free of charge. The recall began on August 19, 2016. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIFF-100.
What a tech checks: Mostly adjustments and wear: steps that stop halfway on a bad switch, doors out of alignment after a slide shifted, exterior lights with a corroded ground. Before you buy: Every door, lock, window and light.
Structure, roof and leaks: 1 recall
Recall 12V526000 (31/10/2012): STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
Tiffin Motorhomes is recalling certain model year 2010-2013 Allegro Bus motorcoaches, manufactured from March 2010, through September 2012 and equipped with a Cummins EPA 2010 ISL engine. Insufficient shielding between the exhaust pipe and floor may cause possible overheating of the floor above the engine compartment.
Fix: Tiffin Motorhomes will notify owners, and dealers will install a heat shield, free of charge. The safety recall began on November 14, 2012. Owners may contact Tiffin at 1-256-356-8661.
What a tech checks: Roof sealant, seams, window and slide seals, and the frame. Water intrusion shows up as delamination, soft floors and stained ceilings months after the leak started. Before you buy: Press the sidewalls and walk the floor; look at every seam and seal.
Roof, leaks and body lessons · Seals and leaks guide
Axles, brakes, suspension and hitch: 1 recall
Recall 09V496000 (29/12/2009): SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
TIFFIN IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 ALLEGRO BUS MODELS WITH POWERGLIDE CHASSIS EQUIPPED WITH PNEUMATIC AND HYDRAULIC ADJUSTABLE BRAKE PEDAL ASSEMBLIES P/NOS. 6562618, 6565118, 77025-001, 77025-002, 77025-501, 77050-004, SUPPLIED BY KONGSBERG AUTOMOTIVE. SOME ASSEMBLIES COULD CONTAIN A DRIVE PIN THAT IS BELOW SPECIFICATION AND MAY BECOME DISENGAGED FROM THE BRAKE ARM CAUSING SEPARATION OR LOOSENING OF THE PEDAL FROM THE REMAINDER OF THE ASSEMBLY.
Fix: TIFFIN IS WORKING WITH KONGSBERG TO REMEDY THESE MOTORHOMES. PLEASE SEE KONGSBERG'S DEFECT REPORT 09E-064. KONGSBERG WILL SUPPLY KITS TO TIFFIN. THE REMEDY WILL BE PERFORMED BY TIFFIN FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 19, 2010. OWNERS MAY CONTACT TIFFIN AT 1-256-356-8661.
What a tech checks: Bearings, brake magnets, worn shackle bolts and bent axles. A trailer that wears tires on the inside edge or pulls to one side usually has an axle or suspension problem. Before you buy: Bolts tight, springs not flat, brakes apply with the breakaway pin pulled.
Chassis and towing lessons · Trailer guide
What owners reported to NHTSA
02/19/2015, EXTERIOR LIGHTING: I RECEIVED RECALL NOTICE 14V-271. IT REQUIRES AN INLINE FUSE TO PREVENT POSSIBLE FIRES. IT DOES NOT ADDRESS THE ISSUE WHICH IS WATER GETTING INTO THE FRONT AND REAR CLEARANCE LIGHTS AND CAUSING THEM TO BECOME INOPERATIVE. WHICH MEANS THE VEHICLE WILL BE WITHOUT THE AFFECTIVE LIGHTS DURING OPERATION. THE FAILURE IS ALMOST UNIVERSALLY SURE TO OCCUR.... SUGGEST THAT THE MANUFACTURE REPLACE THE LIGHTS TO ASSURE COM
Looking at a 2010 Tiffin Allegro Bus?
The Buyer's Check walks you through it on your phone: what to ask, the outside walk-around, water damage, every system on every power source, with the recalls above built in. You get a report that says what's a walk-away and what to negotiate on.
Checked against NHTSA 2026-10-23. Recall repairs are free at an authorized dealer. Complaints are owner reports to NHTSA and are not verified.