2022 Tiffin Allegro Open Road problems: recalls, complaints and what to check
NHTSA has 0 recalls and 20 owner complaints on file for the 2022 Tiffin Allegro Open Road. Here is what they are, what a technician checks for each kind of fault, and how to look one over before you buy it.
Other: 17 complaints
Structure, roof and leaks: 8 complaints
What a tech checks: Roof sealant, seams, window and slide seals, and the frame. Water intrusion shows up as delamination, soft floors and stained ceilings months after the leak started. Before you buy: Press the sidewalls and walk the floor; look at every seam and seal.
Roof, leaks and body lessons · Seals and leaks guide
Axles, brakes, suspension and hitch: 3 complaints
What a tech checks: Bearings, brake magnets, worn shackle bolts and bent axles. A trailer that wears tires on the inside edge or pulls to one side usually has an axle or suspension problem. Before you buy: Bolts tight, springs not flat, brakes apply with the breakaway pin pulled.
Chassis and towing lessons · Trailer guide
LP gas and gas appliances: 1 complaint
What a tech checks: Regulator, lines and fittings, then the appliances: furnace, water heater, range. A proper pressure-drop leak test is the first thing a tech does on an LP complaint. Before you buy: Smell for gas with the tank open; have a shop do the leak test.
LP and furnace lessons · Furnace guide · Furnace 3D lab · Water heater 3D lab
12 volt and 120 volt electrical: 1 complaint
What a tech checks: Voltage drop, grounds, the converter and the transfer switch. Melted shore-cord plugs and bad grounds cause most of the electrical complaints techs actually see. Before you buy: Battery at rest, converter output on shore power, GFCI test, every outlet.
12 V electrical lessons · 120 V and generator lessons · Wiring diagrams
Doors, windows, steps and lights: 1 complaint
What a tech checks: Mostly adjustments and wear: steps that stop halfway on a bad switch, doors out of alignment after a slide shifted, exterior lights with a corroded ground. Before you buy: Every door, lock, window and light.
What owners reported to NHTSA
12/19/2022, STRUCTURE,EQUIPMENT: The contact owns a 2022 Tiffin Allegro Open Road RV. The contact stated that while driving 60 MPH on the interstate, all four of the RV sliders detached. The RV was taken to a dealer where the front sliders were repaired; however, the rear sliders were not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 120,000. The VIN was not available.
11/29/2023, UNKNOWN OR OTHER,STRUCTURE,EQUIPMENT: Purchased Dec 2021. Immediate Hydraulic leak, repaired at dealer. Jan 2022- hydraulic slides creeping out 6-8 inches. March 2022- serviced at Tiffin in Red Bay. No solution for creepy slide. July 2022- received recall for creepy slide. Nov. 2022- Feb 2023. Picked up RV on Feb 9 at service center, completed recall for creepy slide. Before leaving service center, hydraulic pump went out and had to be replaced.
11/28/2023, STRUCTURE: Vehicle was part of a recall for a hydraulic slide issue where the slide that would move out of the RV body during driving 3 to 6 inches. New cylinders fixed the issue for about 10 months. Slide is moving out again during driving which could cause an accident. All owners who had the recall performed have had the new part fail within 6-12 months creating a new safety hazard which could cause death or serious injury f
09/06/2022, SUSPENSION: Front Suspension bump stops are missing. This prevents suspension compression up to a safe amount.
09/05/2023, SEAT BELTS: Seat belt retaining nut fell drivers seatbelt off while driving. This is top point on wall that hold too Section of seat belt. Found passenger side finger tight too.
07/23/2026, FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM: In troubleshooting a power failure in the slide and leveling hydraulic system in this Class A RV, an electrical issue was discovered with the main powerline being frayed and corroded due to its placement next to the gas tank. It appears the power line may have been arching against the fuel tank. This seems like a very dangerous situation and should be reviewed. No incidents happened due to the discovery of this issue
Looking at a 2022 Tiffin Allegro Open Road?
The Buyer's Check walks you through it on your phone: what to ask, the outside walk-around, water damage, every system on every power source, with the recalls above built in. You get a report that says what's a walk-away and what to negotiate on.
Checked against NHTSA 2026-10-23. Recall repairs are free at an authorized dealer. Complaints are owner reports to NHTSA and are not verified.