2024 Tiffin Allegro Open Road problems: recalls, complaints and what to check
NHTSA has 2 recalls and 1 owner complaint on file for the 2024 Tiffin Allegro Open Road. Here is what they are, what a technician checks for each kind of fault, and how to look one over before you buy it.
LP gas and gas appliances: 2 recalls
Recall 23V804000 (29/11/2023): EQUIPMENT:RECREATIONAL VEHICLE/TRAILER:LPG SYSTEMS
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2024 Allegro Open Road and Allegro Bay motorhomes. The 32-inch hard line LPG hose fitting may not fit correctly, which can cause a fuel leak.
Fix: Dealers will replace the 32-inch hose with a 40-inch hose, free of charge. Owner notification letters are expected to be mailed January 28, 2024. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-134.
Recall 24V260000 (11/04/2024): EQUIPMENT:APPLIANCE:OVEN/STOVE/COOKTOP
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2022-2024, Allergro RED 360, 2023-2024 Allergro Open Road, and 2024 Byway, motorhomes. The LED backlight circuit board in the cooktop range may fail, causing the board to overheat.
Fix: Dealers can remove the LED backlights or terminate the circuit for the red LED lights, free of charge. Owner notification letters were mailed by May 21, 2024. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-138.
What a tech checks: Regulator, lines and fittings, then the appliances: furnace, water heater, range. A proper pressure-drop leak test is the first thing a tech does on an LP complaint. Before you buy: Smell for gas with the tank open; have a shop do the leak test.
LP and furnace lessons · Furnace guide · Furnace 3D lab · Water heater 3D lab
Structure, roof and leaks: 1 complaint
What a tech checks: Roof sealant, seams, window and slide seals, and the frame. Water intrusion shows up as delamination, soft floors and stained ceilings months after the leak started. Before you buy: Press the sidewalls and walk the floor; look at every seam and seal.
Roof, leaks and body lessons · Seals and leaks guide
Other: 1 complaint
What owners reported to NHTSA
08/12/2024, STRUCTURE,EQUIPMENT: The contact owns a 2024 Tiffin Open Road RV. The contact stated that while driving approximately 65 MPH, the driver's side slide out room erroneously activated and extended out. The contact stated that the failure also occurred while the RV was parked and turned off. The contact also stated that shortly after obtaining the RV, it was discovered that hydraulic fluid was leaking from the RV. The cause of the failure wa
Looking at a 2024 Tiffin Allegro Open Road?
The Buyer's Check walks you through it on your phone: what to ask, the outside walk-around, water damage, every system on every power source, with the recalls above built in. You get a report that says what's a walk-away and what to negotiate on.
Checked against NHTSA 2026-10-23. Recall repairs are free at an authorized dealer. Complaints are owner reports to NHTSA and are not verified.