2021 Tiffin Wayfarer problems: recalls, complaints and what to check
NHTSA has 2 recalls and 6 owner complaints on file for the 2021 Tiffin Wayfarer. Here is what they are, what a technician checks for each kind of fault, and how to look one over before you buy it.
Other: 9 complaints
Axles, brakes, suspension and hitch: 1 recall
Recall 21V610000 (05/08/2021): TRAILER HITCHES
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2017-2022 Wayfarer motorhomes. Continuous stress on the frame rail hitch extensions may cause them to fail.
Fix: Dealers will inspect and replace the hitch and reinforce the frame rail extension, free of charge. Owner notification letters were mailed November 29, 2021. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is WAY-101.
What a tech checks: Bearings, brake magnets, worn shackle bolts and bent axles. A trailer that wears tires on the inside edge or pulls to one side usually has an axle or suspension problem. Before you buy: Bolts tight, springs not flat, brakes apply with the breakaway pin pulled.
Chassis and towing lessons · Trailer guide
Water and plumbing: 1 recall
Recall 21V753000 (28/09/2021): EQUIPMENT:RECREATIONAL VEHICLE/TRAILER:PLUMBING:POTABLE WATER:STORAGE TANK
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2018-2022 Wayfarer vehicles. The rear-center holding tank water pan bolts may pull through the lip of the pan, allowing the tank to drop down onto the exhaust pipe.
Fix: Dealers will inspect and as necessary, replace any damaged holding pans. In addition, metal straps and a washer plate will be installed. Repairs will be performed free of charge. Owner notification letters were mailed November 29, 2021. Owners may contact Tiffin customer services at 1-256-356-8661. Tiffin's number for this recall is WAY-102.
What a tech checks: Pumps that cycle, fittings that split after a freeze, and tank valves. Most plumbing complaints are leaks from fittings behind walls, found with the pump running and the taps closed. Before you buy: Pump on, taps closed: it should stop and stay stopped.
Water and plumbing lessons · Water pump guide
Structure, roof and leaks: 1 complaint
What a tech checks: Roof sealant, seams, window and slide seals, and the frame. Water intrusion shows up as delamination, soft floors and stained ceilings months after the leak started. Before you buy: Press the sidewalls and walk the floor; look at every seam and seal.
Roof, leaks and body lessons · Seals and leaks guide
What owners reported to NHTSA
11/24/2021, FORWARD COLLISION AVOIDANCE,LANE DEPARTURE: All driver assist functions randomly shut down and start working again. It may work correctly all day and then the next day it might work for 30 minutes or an hour or not at all. It has been to Mercedes for this problem, I don't think they know how to fix it. Based on the number of people I read having the same problem. It might be related to computer hardware being hard to get, makes it hard to drive much distance w
08/13/2023, UNKNOWN OR OTHER: The vehicle is a recreation vehicle with a door in the added cabin on a Mercedes chassis. There are automatic extended steps mounted under the door opening. They have failed several times during travel. Sometimes they extend while driving striking curbs and the like. Sometimes they fail to extend and lead to falls while opening the door to exit the vehicle. Tiffin knows of the problem, but it seems to be a design fla
06/13/2022, FORWARD COLLISION AVOIDANCE,LANE DEPARTURE: Vehicle flashed a warning that Active Distance Assistance was not functional, and within a few minutes started to veer left, as if there was a flat tire (which there was not), so I was trying to keep it centered in my lane when the steering wheel suddenly turned counterclockwise in my hands and swerved the vehicle to the hard left into an oncoming lane. I had to hit the brakes hard and yank the steering wheel back to
06/07/2022, UNKNOWN OR OTHER: The Tiffin Wayfarer is built on a MB Sprinter 3500 chassis. Tiffin adds rear wheelwell liners made of plastic. These liners are held onto the chassis by 4 screws all on the outside of the liner. There is no inside support of the liner or reinforcement of the screws. My right side liner detached while traveling on I-81 in PA at 65 mph. It went under the wheels which caused the vehicle to bounce and it acted like a bl
03/09/2023, STRUCTURE,UNKNOWN OR OTHER: While driving down the road, the power door steps will spontaneously extend. This extends close to the ground and out to the side, and could catch on a curb, pothole, another vehicle, etc. This could cause an accident many different ways. It has been to the dealer for service multiple times, details below. The issue persists. I have learned from Facebook groups that this issue is quite widespread and they se
01/04/2022, VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE: Cruise control disengagement . Abrupt ceasing interferes with anti collision and speed control causing slowing speeds without warning, could be a risk to those following as well disrupting the flow of traffic. The vehicle has been inspected by 3 MB service technicians. 1 .MB of Selma, TX-09/2021 2. MB of Boerne, TX-09/2021 3. MB of Birmingham, AL @ Casa Grande, AZ-Tiffin Rally-10/2021 All 3 dealers confirmed probl
Looking at a 2021 Tiffin Wayfarer?
The Buyer's Check walks you through it on your phone: what to ask, the outside walk-around, water damage, every system on every power source, with the recalls above built in. You get a report that says what's a walk-away and what to negotiate on.
Checked against NHTSA 2026-10-23. Recall repairs are free at an authorized dealer. Complaints are owner reports to NHTSA and are not verified.